Perkins 403F-E17T 404F-E22T - Page 105

Exhaust Gas Recirculation Valve - Clean ....... 92
F
Fan Clearance - Check ................................... 93
Four Cylinder Turbocharged........................ 94
Four Cylinder Turbocharged Aftercooled .... 94
Three Cylinder ............................................. 94
Fault Logging................................................... 44
Features and Controls..................................... 38
Fire Prevention and Explosion Prevention...... 14
Ether ............................................................ 15
Fire Extinguisher.......................................... 15
Lines, Tubes, and Hoses ............................. 16
Fluid Recommendations ........................... 58, 67
ELC Cooling System Maintenance.............. 70
Engine Oil .................................................... 58
General Coolant Information ....................... 67
General Lubricant Information..................... 58
Fluid Recommendations (General Fuel
Information) ................................................... 60
Contamination Control Recommendations for
Fuels .......................................................... 67
Diesel Fuel Characteristics.......................... 63
Diesel Fuel Requirements ........................... 60
Fuel Cleaner ................................................ 66
General Information..................................... 60
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 54
Fuel Conservation Practices ........................... 49
Fuel Related Components in Cold Weather ... 55
Fuel Filters ................................................... 55
Fuel Heaters ................................................ 55
Fuel Tanks ................................................... 55
Fuel System - Prime........................................ 94
Fuel System Primary Filter (Water
Separator) Element - Replace....................... 95
Remove the Element ................................... 95
Fuel System Primary Filter/Water
Separator - Drain ........................................... 96
Fuel System Secondary Filter - Replace ........ 96
Remove the Filter Element .......................... 97
Fuel System Secondary Filter/Water
Separator - Drain ........................................... 97
Fuel Tank Water and Sediment - Drain ........... 98
Drain the Water and the Sediment .............. 98
Fuel Storage Tanks...................................... 98
Fuel Tank ..................................................... 98
G
Gauges and Indicators .................................... 38
General Hazard Information.............................. 9
Containing Fluid Spillage..............................11
Dispose of Waste Properly .......................... 12
Fluid Penetration ......................................... 10
Inhalation ......................................................11
Pressurized Air and Water........................... 10
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ........................11
General Information ........................................ 23
H
High Pressure Fuel Lines ................................ 16
Four Cylinder engine ................................... 18
Three Cylinder Engine................................. 19
Hoses and Clamps - Inspect/Replace............. 98
Replace the Hoses and the Clamps............ 99
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 35
M
Maintenance Interval Schedule....................... 75
Commissioning ............................................ 75
Daily ............................................................. 75
Every 1000 Service Hours........................... 75
Every 12 000 Service Hours or 6 Years....... 75
Every 1500 Service Hours........................... 75
Every 2000 Service Hours........................... 75
Every 3000 Service Hours........................... 75
Every 3000 Service Hours or 2 Years ......... 75
Every 4000 Service Hours........................... 75
Every 50 Service Hours or Weekly.............. 75
Every 500 Service Hours............................. 75
Every 500 Service Hours or 1 Year ............. 75
Every 6000 Service Hours or 3 Years ......... 75
When Required............................................ 75
Maintenance Recommendations .................... 72
Maintenance Section....................................... 57
Model View Illustrations .................................. 23
SEBU9075-03
105
Index Section