Perkins 403J-E17T - Page 123

Engine Operation with Active Diagnostic
Codes ............................................................ 46
Engine Operation with Intermittent
Diagnostic Codes .......................................... 46
Engine Protection Plans (Extended Service
Contract)...................................................... 121
Engine Starting.......................................... 21, 47
Engine Stopping........................................ 21, 57
Engine Valve Lash - Check ........................... 103
F
Fan Clearance - Check ................................. 104
Four Cylinder Turbocharged...................... 104
Four Cylinder Turbocharged Aftercooled .. 104
Three Cylinder ........................................... 104
Fault Logging................................................... 46
Features and Controls..................................... 40
Fire Prevention and Explosion Prevention...... 15
Ether ............................................................ 16
Fire Extinguisher.......................................... 16
Lines, Tubes, and Hoses............................. 17
Fluid Recommendations ........................... 68, 73
ELC Cooling System Maintenance.............. 70
Engine Oil .................................................... 74
General Coolant Information ....................... 68
General Lubricant Information..................... 73
Fluid Recommendations (General Fuel
Information) ................................................... 59
Contamination Control Recommendations for
Fuels .......................................................... 67
Diesel Fuel Characteristics.......................... 63
Diesel Fuel Requirements ........................... 60
General Information..................................... 60
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 55
Fuel Conservation Practices ........................... 52
Fuel Related Components in Cold Weather ... 56
Fuel Filters ................................................... 56
Fuel Heaters ................................................ 56
Fuel Tanks ................................................... 56
Fuel System - Prime...................................... 104
Hand Priming (If Equipped) ....................... 106
Fuel System Primary Filter (Water
Separator) Element - Replace..................... 106
Remove the Element ................................. 106
Fuel System Primary Filter (Water
Separator) Element - Replace (Primary
Fuel Filter With Water In Fuel (WIF)
Sensor) ........................................................ 107
Install the New Filter Element.................... 108
Remove the Element ................................. 107
Fuel System Primary Filter/Water
Separator - Drain ..........................................110
Fuel System Primary Filter/Water
Separator - Drain (Primary Fuel Filter With
Water In Fuel (WIF) Sensor) ....................... 109
Fuel System Secondary Filter - Replace .......111
Remove the Filter Element .........................111
Fuel System Secondary Filter/Water
Separator - Drain ..........................................113
Fuel Tank Water and Sediment - Drain ..........113
Drain the Water and the Sediment .............114
Fuel Storage Tanks.....................................114
Fuel Tank ....................................................113
G
Gauges and Indicators .................................... 40
General Hazard Information............................ 10
Containing Fluid Spillage..............................11
Dispose of Waste Properly .......................... 13
Fluid Penetration ..........................................11
Inhalation ..................................................... 12
Pressurized Air and Water............................11
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 12
General Information ........................................ 24
H
High Pressure Fuel Lines................................ 17
Four Cylinder engine ................................... 19
Three Cylinder Engine................................. 20
Hoses and Clamps - Inspect/Replace............114
Replace the Hoses and the Clamps...........115
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 36
M0094137-02 123
Index Section