Philips Saeco GranBaristo User Manual

All parts of this document are the property of Saeco International Group.
All rights reserved. is document and all the information herein is provided without liability deriving from any errors or omissions. Furthermore, no part may be reproduced, used or
collected, except where express authorisation has been provided in writing or through a contractual agreement.
Published by Saeco International Group
Subject to modication EN 4219 400 00022
Service
Coee Machine
GranBaristo
GranBaristo V2
GranBaristo
Avanti V2
GranBaristo
Avanti
2013-Sept.-02
Service Manual
Rev. 05 MAY 2016
TECHNICAL INFORMATION
Power supply and output: 240 V~ 50 Hz 1900W - 230 V~ 50/60 Hz 1900 W 120 V~ 60 Hz 1300 W
Temperature monitoring: (NTC) variable resistor sensor - transmits the value to the electronic card
Safety system: 2 thermostats at 190°C one shot
Coee heat exchanger output: Stainless steel
for coee, hot water and steam dispensing
(230 V~) 1900 W - (120 V~) 1300 W - (100 V~) 1100 W
Dimensions: W x H x D in mm: 210 x 360 x 460 mm
Stand-by power consumption < 0,5W
Weight: 13 kg
Water tank capacity: 1.7 l
Coee bean hopper capacity: 270 g. of coee beans
Dreg drawer capacity: 20
Heating time: Approx. 45 sec.
Water circuit lling time: Approx. 15 sec Max. on rst lling cycle
Power consumption: During heating phase- approx. 5.6 A
Automatic dosage: Dose adjustment controlled by the electronic system
Material
Housing ABS/ABS+PMMA/METAL
Beans container ABS
Water tank SAN
Dreg drawer ABS

Philips Saeco GranBaristo Specifications

General

Coffee Strength Settings	5
Milk System	Integrated Milk Carafe
Pump Pressure	15 bar
Adjustable Coffee Volume	Yes
Adjustable Temperature	Yes
Removable Brewing Unit	Yes
Number of Coffee Strengths	5
Number of Grinder Settings	5
Programmable	Yes
Color	Black
Type	Super-automatic espresso machine
Voltage	220-240 volts

Summary

CHAPTER 1 INTRODUCTION

1.4 Safety Warnings

Provides crucial safety precautions and warnings for operation and repair.

CHAPTER 2 TECHNICAL SPECIFICATIONS

2.1 Technical Specifications

Lists general technical data for the coffee machine.

2.2.1 Coffee Product Temperature Measurement

Details the procedure for measuring coffee temperature.

2.2.2 Milk Product Temperature Measurement

2.3 Machine Parameters and Performance GranBaristo V2

Specifies performance parameters for the GranBaristo V2 model.

2.4 Machine Parameters and Performance GranBaristo

Specifies performance parameters for the GranBaristo model.

2.5 Oil Leakage Check in Piston Assembly

Provides steps to diagnose oil leakage in the piston assembly.

CHAPTER 3 BRIEF INSTRUCTIONS

CHAPTER 4 OPERATING LOGIC

4.1.1 Water Circuit Granbaristo

4.2 Coffee Cycle

CHAPTER 5 SERVICE MODE

5.1.1 Test Mode GranBaristoV2/AvantiV2

Guides on entering and using the test mode for V2/AvantiV2 models.

5.1.2 Diagnostic Mode GranBaristoV2/AvantiV2

Explains how to access and navigate diagnostic modes.

5.1.3 Error Codes

Lists and describes various error codes for the machine.

5.2.1 Test Mode GranBaristo Avanti

Guides on entering and using the test mode for Avanti models.

5.2.2 Test Mode GranBaristo

Guides on entering and using the test mode for GranBaristo models.

5.2.3 Diagnostic Mode GranBaristo/Avanti

Explains how to access and navigate diagnostic modes for GranBaristo/Avanti.

5.3 Saeco Service Center Quick Start Guide

Introduces the Saeco Service Center tool for programming and diagnostics.

CHAPTER 6 SERVICING AND MAINTENANCE

6.1 Repair Flow

Outlines the step-by-step process for repairing the coffee machine.

CHAPTER 7 DISASSEMBLY

7.1 Outer Shell GranBaristo/V2

Provides instructions for removing the outer casing of the machine.

7.3 Coffee Grinder