101
MAINTENANCE
Periodic Maintenance Schedule (Cont.)
" More often under severe use, such as dirty or wet
conditions to purge water or dirt contamination from grease
fittings and other critical components.
L Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty. Please refer to your owner’s manual supple-
ment to determine if this applies to your vehicle.
Item Hours
or
Miles
When Remarks
"
L
Engine breather fil-
ter
(4-cycle)
20 hrs Monthly Inspect--replace annual-
ly and as needed
J Brake pad wear 10 hrs Monthly Inspect periodically
" Front and Rear
Gearcase Oil
(shaft drive)
100 hrs Monthly Check monthly and
change annually
Engine Cylinder
Head and
Cylinder Base Fas-
teners
25 hrs 3
months
Inspect (re-torque re-
quired at first service
only)
" General Lubrica-
tion
50 hrs 3
months
Lubricate all fittings, piv-
ots, cables, etc.
Due to the nature of the adjustments marked with a J on the
following chart
, it is recommended that service be performed by
an authorized Polaris dealer.
To Next Page
Loading...
Need help?
General
