103
MAINTENANCE
Periodic Maintenance Schedule (Cont.)
" More often under severe use, such as dirty or wet
conditions to purge water or dirt contamination from grease
fittings and other critical components.
L Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty. Please refer to your owner’s manual supple-
ment to determine if this applies to your vehicle.
Item Hours
or
Miles
When Remarks
" Front Suspension 50 hrs 6
months
Inspect--lubricate, tight-
en fasteners
" Rear Suspension 50 hrs 6
months
Inspect, tighten fasten-
ers
" Drive Chain(s) 50 hrs 6
months
Inspect daily, adjust and
lubricate if needed
L Spark Plug 100 hrs 12
months
Inspect--replace if nec-
essary
J
L
Ignition T iming 100 hrs 12
months
Inspect and adjust as
needed
J
L
Fuel System 100
hours
12
months
Check for leaks at tank
cap, lines, fuel valve, fil-
ter , pump and carbure-
tor . Replace lines every
two years.
J Fuel Filter 100 hrs 12
months
Replace annually
Due to the nature of the adjustments marked with a J on the
following chart
, it is recommended that service be performed by
an authorized Polaris dealer.
To Next Page
Loading...
