52
MAINTENANCE
Periodic Maintenance Chart
Perform these procedures more often for vehicles subjected to severe use.
E Emission-Related Service
D Have an authorized POLARIS dealer perform these services.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
Front Suspension 50 H 6 M - Lubricate
Rear Suspension 50 H 6 M - Lubricate
D
E
Throttle cable/ ETC switch 50 H 6 M - Inspect; adjust; lubricate; replace if nec-
essary
E Throttle body air intake ducts/
flange
50 H 6 M - Inspect duct for proper sealing/air leaks
Drive belt 50 H 6 M - Inspect; adjust; replace as needed
Cooling system (if applicable) 50 H 6 M - Inspect coolant strength seasonally;
pressure test system yearly
Park brake cable tension 100 H 6 M - Check tension, adjust
Engine oil change 100 H - - After break-in oil change at 50 hours,
change oil and filter every 100 hours
Oil filter change 100 H - - Replace with oil change
Front Gearcase oil (if equipped) 100 H 6 M - Inspect level; change yearly
Middle Gearcase oil (if equipped) 100 H 6 M - Inspect level; change yearly
Rear gearcase oil (if equipped) 100 H 6 M - Inspect level; change yearly
Transmission oil 100 H 6 M - Inspect level; change yearly
D
E
Fuel system 100 H 12 M - Check for leaks at tank cap, lines, fuel
valve, filter, pump, throttle body; replace
lines every 2 years
Radiator (in applicable) 100 H 12 M - Inspect; clean external surfaces
Cooling Hoses 100 H 12 M - Inspect for leaks
Engine mounts 100 H 12 M - Inspect
Exhaust muffler/pipe 100 H 12 M - Inspect
Wiring 100 H 12 M - Inspect for wear, routing, security; apply
dielectric grease to connectors sub-
jected to water, mud, etc.
D
Clutches (drive and driven) 100 H 12 M - Inspect; clean; replace worn parts
D Front wheel bearings 100 H 12 M - Inspect; replace as needed
D
E
Air filter, main element 150 H - Replace
D Fuel filter/water separator 150 H 12 M - Replace
D Brake fluid 200 H 24 M - Change every two years
D Fuel system 200 H 24 M - Replace lines every 2 years
Spark arrester 300 H 36 M - Clean out
D Toe adjustment - Inspect periodically; adjust when parts
are replaced
D
Auxiliary brake (if equipped) - Inspect daily; adjust as needed
Headlight aim - Adjust as needed
To Next Page
Loading...
Need help?
General
