82
TROUBLESHOOTING
Park Brake Alarm Fails to Turn Off
Engine Doesn't Turn Over
Engine Turns Over, Fails to Start
Engine Backfires
Possible Cause Solution
Park brake is not completely disengaged Ensure lever is in forward-most position
Park brake connector malfunction or switch move-
ment or failure
Disconnect the connector if temporary continued
operation is necessary, see your dealer promptly for
service
Possible Cause Solution
Low battery voltage Recharge the battery to 12.8 VDC
Loose battery connections Check all connections and tighten
Loose solenoid connections Check all connections and tighten
Loose electronic control box connections Inspect, clean, reinstall connectors
Possible Cause Solution
Out of fuel Refuel
Clogged fuel filter/water separator Replace
Clogged air filter Replace
Water is present in fuel Drain the fuel system and refuel, replace fuel filter/
water separator
Old or non-recommended fuel Replace with fresh recommended fuel
Water or fuel in crankcase Immediately see your POLARIS dealer
Low battery voltage Recharge the battery to 12.8 VDC
Mechanical failure See your dealer
Defective glow plug Inspect and replace
Defective stop solenoid Replace
Defective fuel pump Replace
Possible Cause Solution
Old or non-recommended fuel Replace with fresh recommended fuel
Loose ignition connections Check all connections and tighten
Water present in fuel Replace with fresh recommended fuel
To Next Page
Loading...
Need help?
General
