Vehicles subjected to severe use must be serviced at 50% of the stated interval.
Examples of Severe Use: Frequent immersion in mud, water, or sand, constant
high RPM use, prolonged low-speed heavy load operation, extended idle, and
short trip cold weather operation.
EVERY 50 HOURS / 500 MILES (800 KM)
Battery
Check terminals; terminals should be tight and
free of corrosion. Clean, test, and replace as
necessary.
Brake System
Inspect for fluid leaks; add recommended brake
fluid from a sealed container if needed.
Engine Oil and Filter Change the engine oil and filter.
Front / Rear Suspension
Lubricate.
Fuel System / Filter*
Inspect; cycle key to pressurize fuel pump;
check for leaks at fuel system connections,
check for leaks at fill cap.
General Lubrication
Locate all applicable fittings and grease.
Shift Cable / Linkage Inspect; adjust; lubricate.
Steering Components
Lubricate.
Suspension Components*
Inspect tie rods, wheel bearings, suspension
bushings, and ball joints for loose or worn
components; replace as needed. Inspect shock
absorbers for leaks or damage.
Throttle Body Intake Ducts
/ Flanges
Inspect for proper sealing and air leaks.
Wheels / Tires / Lug Nuts Inspect; replace as needed.
Valve Lash*
Inspect; adjust as needed.
* Have an authorized Polaris dealer or other qualified person perform these
services.
89
MAINTENANCE
To Next Page
Loading...
Need help?
General
