EasyManua.ls Logo

Poulan Pro PB145G42 - User Manual

Poulan Pro PB145G42
60 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
OPERATOR'S MANUAL
MODEL:
PB145G42
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulanpro.com
WARNING:
Read this Man u al and follow all Warnings
and Safety Instructions. Fail ure to do so can
re sult in serious in ju ry.
IMPORTANT MANUAL Do Not Throw Away
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.
09.10.14 BD
Printed in the U.S.A.
587 62 82-27

Table of Contents

Other manuals for Poulan Pro PB145G42

Preview: Repair Parts Manual
Repair Parts Manual20 pages

Questions and Answers

  • R
    Rachel CooperAug 19, 2025
    Why Poulan Pro Lawn Mower will not start?
    • L
      lyonsbrittanySep 12, 2025
      Your Poulan Pro Lawn Mower might not start due to several reasons: it may be out of fuel, so fill the fuel tank. The engine may not be choked properly, refer to the “TO START ENGINE” section in the Operation section. The engine could be flooded, wait several minutes before trying again. Other potential causes include a bad spark plug (replace it), a dirty air filter (clean or replace it), a dirty fuel filter (replace it), water in the fuel (empty the tank and carburetor, refill with fresh gasoline, and replace the fuel filter), loose or damaged wiring (check all wiring), or engine valves out of adjustment (contact an authorized service center/department).
  • A
    alejandro29Aug 23, 2025
    How to fix Poulan Pro Lawn Mower that is hard to start?
    • W
      wigginsleslieAug 23, 2025
      If your Poulan Pro Lawn Mower is hard to start, consider these possibilities: The air filter may be dirty, so clean or replace it. The spark plug could be bad, so replace it. A weak or dead battery may be the issue, so recharge or replace the battery. The fuel filter might be dirty, so replace it. The fuel could be stale or dirty, so empty the fuel tank and refill it with fresh, clean gasoline. There might be loose or damaged wiring, so check all wiring. Finally, the engine valves could be out of adjustment, in which case you should contact an authorized service center/department.
  • R
    Randy MartinAug 26, 2025
    What to do if Poulan Pro PB145G42 Lawn Mower engine will not turn over?
    • E
      Elizabeth TravisAug 26, 2025
      If the engine of your Poulan Pro Lawn Mower won't turn over, make sure the clutch/brake pedal is depressed. Also, ensure the attachment clutch is disengaged. Other potential issues include a weak or dead battery (recharge or replace it), a blown fuse (replace it), corroded battery terminals (clean them), loose or damaged wiring (check all wiring), a faulty ignition switch (check/replace it), or a faulty solenoid or starter (check/replace them). For faulty operator presence switch(es), contact an authorized service center/department.
  • T
    Teresa SheppardAug 30, 2025
    What to do if Poulan Pro PB145G42 engine clicks but will not start?
    • K
      Kristin RichardsAug 30, 2025
      If your Poulan Pro Lawn Mower engine clicks but doesn't start, the battery may be weak or dead, so recharge or replace it. Also, the battery terminals might be corroded, so clean them. Check for loose or damaged wiring and repair as needed. A faulty solenoid or starter could also be the problem, so check and replace if necessary.
  • R
    Ruben BurnsSep 2, 2025
    Why Poulan Pro Lawn Mower has poor cut that is uneven?
    • S
      Stacy DiazSep 2, 2025
      An uneven cut with your Poulan Pro Lawn Mower can be caused by a worn, bent, or loose blade, so replace the blade and tighten the blade bolt. The mower deck might not be level, so level the mower deck. Buildup of grass, leaves, or trash under the mower can also cause an uneven cut, so clean the underside of the mower housing. Additionally, a bent blade mandrel can be the cause, so replace the blade mandrel. Finally, clogged mower deck vent holes from buildup of grass, leaves, and trash around mandrels can contribute to an uneven cut, so clean around mandrels to open vent holes.
  • J
    Jonathan SmithSep 4, 2025
    What to do if Poulan Pro PB145G42 blades will not rotate?
    • C
      Connie SaundersSep 4, 2025
      If the mower blades of your Poulan Pro Lawn Mower won't rotate, check for an obstruction in the clutch mechanism and remove it. Also, inspect the mower drive belt for wear or damage and replace it if necessary. A frozen idler pulley can also prevent blade rotation, so replace the idler pulley. Lastly, a frozen blade mandrel can be the cause, so replace the blade mandrel.
  • T
    Terri CarneySep 6, 2025
    Why Poulan Pro Lawn Mower has excessive vibration?
    • D
      Destiny DunnSep 6, 2025
      Excessive vibration in your Poulan Pro Lawn Mower may be due to a worn, bent, or loose blade, so replace the blade and tighten the blade bolt. Another cause could be a bent blade mandrel, which requires replacement. Finally, loose or damaged parts can cause vibration, so tighten any loose parts and replace any damaged parts.
  • J
    Juan WilliamsSep 8, 2025
    Why Poulan Pro Lawn Mower headlight(s) not working?
    • X
      xjohnsonSep 8, 2025
      If the headlight(s) on your Poulan Pro Lawn Mower are not working, first check if the switch is “OFF” and turn it “ON”. If that's not the issue, the bulb(s) or lamp(s) may be burned out, so replace them. A faulty light switch could also be the problem, so check and replace it. Additionally, check the wiring and connections for any looseness or damage. Finally, a blown fuse could be the cause, so replace the fuse.
  • S
    Sean McmillanSep 12, 2025
    Why Poulan Pro PB145G42 Lawn Mower battery will not charge?
    • L
      lori17Sep 12, 2025
      If your Poulan Pro Lawn Mower battery won't charge, it could be due to bad battery cell(s), in which case you should replace the battery. Poor cable connections can also prevent charging, so check and clean all connections. If your mower is equipped with a regulator, a faulty regulator could be the issue, so replace the regulator. Lastly, a faulty alternator can prevent the battery from charging, so replace the alternator.
  • N
    Nicole VincentSep 13, 2025
    What causes Poulan Pro PB145G42 Lawn Mower engine to "backfires” when turning engine “OFF”?
    • D
      David ButlerSep 13, 2025
      The Poulan Pro Lawn Mower engine "backfires” when turning engine “OFF” because the engine throttle control is not set between half and full speed (fast) position before stopping engine. Move throttle control between half and full speed (fast) position before stopping engine.

Summary

OPERATORS MANUAL

SAFETY RULES

I. CHILDREN

Safety precautions for children operating or near the lawn tractor.

II. GENERAL OPERATION

General safe operating practices and essential warnings for tractor use.

III. SLOPE OPERATION

Critical guidelines and warnings for safe operation on sloped terrain.

IV. TOWING

Safety instructions and limitations for towing attachments with the tractor.

V. SERVICE

Procedures for safe handling of gasoline and general maintenance precautions.

PRODUCT SPECIFICATIONS

CUSTOMER RESPONSIBILITIES

UNASSEMBLED PARTS

Steering Wheel

Components related to the steering wheel assembly.

Seat

Components related to the tractor seat assembly.

Keys

Ignition keys for operating the tractor.

Oil Drain Extension

Part used for facilitating engine oil changes.

Slope Sheet

Visual guide for assessing slope angles.

ASSEMBLY

TOOLS REQUIRED FOR ASSEMBLY

List of necessary tools for assembling the tractor.

TO REMOVE TRACTOR FROM CARTON

Steps for safely unpacking the tractor from its shipping container.

INSTALL STEERING WHEEL

Procedure for installing the steering wheel assembly onto the tractor.

INSTALL SEAT

Instructions for properly installing and adjusting the tractor seat.

CHECK TIRE PRESSURE

Importance and procedure for setting correct tire pressure for optimal performance.

OPERATION

KNOW YOUR TRACTOR

Identification and function of tractor controls and their locations.

HOW TO USE YOUR TRACTOR

Step-by-step guide on operating basic tractor functions.

TO START ENGINE

Procedures for starting the tractor engine in different weather conditions.

MOWING TIPS

Advice and best practices for effective and efficient mowing.

MAINTENANCE

MAINTENANCE SCHEDULE

Recommended maintenance intervals for various tractor components.

BEFORE EACH USE

Pre-operation checks to ensure safety and proper function.

TO CHANGE ENGINE OIL

Detailed steps for draining and refilling engine oil for maintenance.

ENGINE COOLING SYSTEM

How to clean the engine cooling system to prevent overheating.

SERVICE AND ADJUSTMENTS

TO REMOVE MOWER

Instructions for detaching the mower deck from the tractor.

TO INSTALL MOWER

Steps for correctly attaching the mower deck to the tractor.

TO LEVEL MOWER

Procedures for adjusting the mower deck for optimal cutting performance.

TO REPLACE MOWER BLADE DRIVE BELT

Guide for replacing the mower blade drive belt.

STORAGE

TRACTOR

General preparation steps for storing the tractor.

ENGINE FUEL SYSTEM

Procedures to prepare the fuel system for long-term storage.

TROUBLESHOOTING

Will not start

Common causes and solutions for the engine failing to start.

Loss of power

Troubleshooting steps for reduced engine power or performance issues.

Poor cut - uneven

Reasons and fixes for uneven or poor lawn cutting results.

SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION

LIMITED WARRANTY

SERVICE NOTES

Poulan Pro PB145G42 Specifications

General IconGeneral
Engine TypeGasoline
Engine Displacement145cc
Engine BrandBriggs & Stratton
Number of Blades2
Number of Gears1
Cutting Height1.25 to 3.75 inches
Cutting Height Positions6
Mulching CapabilityYes
Side DischargeYes
Bagger CompatibilityYes
Cutting Width42 inches
Transmission TypeGear
Fuel Capacity1.5 gal.
Drive SystemRear-wheel drive
Fuel Tank Capacity1.5 gal.
Wheel Size8 inches front, 12 inches rear

Related product manuals