To Next PageTo Next PageWhy Poulan Pro Lawn Mower engine clicks but will not start?
If your Poulan Pro Lawn Mower engine clicks but doesn't start, it could be due to a weak or dead battery; try recharging or replacing it. Corroded battery terminals can also cause this, so clean them. Check for loose or damaged wiring. A faulty solenoid or starter might also be the problem, so check or replace those components.
General| Engine | Briggs & Stratton |
|---|---|
| Transmission | Hydrostatic |
| Deck Material | Steel |
| Fuel Capacity | 1.5 gallons |
| Engine Type | 4-cycle |
| Engine Displacement | 500 cc |
| Cutting Height | 1.5 to 4 inches |
| Drive System | Rear wheel drive |
| Warranty | 2 years |
| Height Adjustment | 6-position |
| Cutting Width | 42 inches |
| Blade Engagement | Electric PTO |
Identifies the specific model of the lawn tractor.
Emphasizes reading and following safety instructions for serious injury prevention.
Crucial safety advice to always wear eye protection during operation.
Guidelines for safe operation of ride-on mowers.
Critical danger warning about amputation and death from the cutting machine.
Warning about disconnecting spark plug wire to prevent accidental starting.
Warning against coasting downhill in neutral to avoid loss of control.
Warning about towing only recommended attachments and safe towing practices.
Warning about chemicals in exhaust known to cause cancer/birth defects.
Warning about lead in battery components causing cancer/birth defects.
Basic rules for operating the tractor safely.
Specific safety guidelines for operating on slopes.
Safety precautions regarding children around the tractor.
Guidelines for safely towing attachments.
Important safety precautions for servicing the tractor.
Critical safety information for handling gasoline.
General service and maintenance safety guidelines.
Specifies the fuel tank capacity and type.
Details the required engine oil type classification.
Specifies the engine oil capacity with and without filter.
Identifies the recommended spark plug type and gap.
Lists the forward and reverse ground speeds.
Describes the tractor's charging system specifications.
Provides battery specifications like AMP/HR, Min. CCA, and Case Size.
Specifies the recommended torque for blade bolts.
Outlines the owner's duties for maintaining the tractor.
Warning about using the tractor on unimproved land without a spark arrester.
Image and label for the tractor key.
Identifies the oil drain tube.
Identifies the tractor keys.
Visual aid for measuring slopes.
Lists necessary tools for assembling the tractor.
Instructions for unpacking the tractor from its carton.
Steps to take before removing the tractor from the skid.
Procedure for checking the tractor's battery.
Instructions for adjusting the tractor seat for comfort and operation.
Steps to safely roll the tractor off its shipping skid.
Importance and procedure for checking tire pressure.
Importance and procedure for checking mower deck levelness.
How to verify the correct routing of mower and drive belts.
How to check if the tractor's brake system is operating correctly.
A checklist of important items to review before operating the tractor.
Key items to focus on while learning to operate the tractor.
Defines the meaning of the DANGER safety symbol.
Defines the meaning of the WARNING safety symbol.
Defines the meaning of the CAUTION safety symbol.
Defines CAUTION when used without an alert symbol.
Defines the HOT SURFACES hazard symbol.
Defines the FIRE hazard symbol.
Encourages familiarization with tractor controls and adjustments.
Explains the function of the attachment clutch lever.
Explains the function of the attachment lift lever.
Explains the function of the clutch/brake pedal.
Explains the function of the motion control lever for speed and direction.
Explains the function of the ignition switch for starting and stopping.
Explains the function of the light switch.
Explains the function of the parking brake.
Explains the ROS "ON" position for reverse operation with attachments.
Explains the function of the throttle/choke control.
Explains the function of the freewheel control.
Explains the service reminder and hour meter function.
Reinforces the importance of wearing safety glasses.
General instructions on how to operate the tractor.
Step-by-step guide to setting the parking brake.
Instructions on how to stop the mower blades and the ground drive.
Guidance on using the throttle control for engine speed.
How to control the tractor's movement using the motion control lever.
Instructions for adjusting the mower's cutting height.
Instructions for adjusting the mower deck gauge wheels.
Explanation of the Reverse Operation System and its usage.
How to safely use the Reverse Operation System.
Steps for operating the mower, including safety features.
Caution about operating the mower without safety devices.
Safety rules for operating the tractor on hills.
Instructions for safely transporting the tractor.
Explanation of the service reminder and hour meter.
Guidelines for towing carts and other attachments.
Pre-start checks and procedures before starting the engine.
Procedure for checking the engine oil level.
Instructions for adding gasoline safely.
Caution regarding spilled oil or fuel and open flames.
Important note on using winter grade gasoline in cold weather.
Caution about alcohol blended fuels and potential engine problems.
Step-by-step guide to starting the tractor engine.
Procedure for starting the engine in warm weather.
Procedure for starting the engine in cold weather.
How to warm up the automatic transmission before driving in cold weather.
Instructions for purging the transmission before initial operation.
Crucial caution about engaging/disengaging freewheel lever.
Important note regarding transmission purging after service.
Caution about potential drive wheel movement during transmission purging.
Practical advice for effective and safe mowing.
Restriction on using tire chains with the mower attached.
Importance of mower deck leveling for optimal performance.
Guidance on using the left side of the mower for trimming.
Technique for discharging clippings for even distribution.
Advice on mowing very tall grass in two passes.
Warning against mowing wet grass due to plugging and clumps.
Recommendation to operate the engine at full throttle for best mowing.
Guidance on selecting ground speed for attachments based on terrain.
A schedule of required maintenance tasks and intervals.
Maintenance tasks specific to the tractor.
Engine maintenance procedures.
General advice for proper tractor maintenance.
Essential checks to perform before each use of the tractor.
A chart detailing lubrication points and types.
Important note about lubricating specific pivot points.
How to check and adjust the brake operation.
Maintenance related to tires, including pressure and care.
How to check the operator presence and ROS systems for proper function.
How to care for mower blades, including sharpening and replacement.
Caution regarding using approved replacement blades.
Step-by-step instructions for removing mower blades.
Maintenance and care for the tractor's battery.
Procedure for cleaning the battery and terminals.
Inspection and replacement of V-belts.
Procedures for maintaining the transaxle, including cleaning.
Information on transaxle fluid maintenance.
Engine maintenance procedures.
How to properly lubricate the engine and its components.
Chart showing SAE viscosity grades for different temperatures.
Note on multi-viscosity oils and oil consumption.
Step-by-step guide to changing the engine oil.
When to replace the engine oil filter.
Importance of servicing the air filter.
How to clean the air screen to prevent engine damage.
How to maintain the engine cooling system for proper operation.
Inspection and potential replacement of the muffler.
When to replace spark plugs and their specifications.
Instructions for replacing the in-line fuel filter.
General cleaning procedures for the tractor.
Warning about pinch points and movable parts during cleaning.
Instructions on how to use the deck washout port for cleaning.
Warning about operating with a broken or missing washout fitting.
Critical safety precautions before performing service or adjustments.
Step-by-step instructions for removing the mower deck.
Caution about the spring-loaded attachment lift lever.
Step-by-step instructions for installing the mower deck.
Caution regarding the spring-loaded lift lever during installation.
Instructions for removing mower links when mounting other attachments.
Note on the orientation of mower side suspension arms.
How to attach the mower side suspension arms to the tractor chassis.
How to attach the rear lift links of the mower.
How to attach the front link of the mower deck.
Connecting the clutch cable spring to the idler arm.
Installing the clutch cable housing guide and collar.
Installing the drive belt onto the engine pulley and belt keepers.
Important check for correct belt routing in mower pulley grooves.
Step for raising the attachment lift lever.
When and how to adjust gauge wheels.
Procedure for leveling the mower deck.
How to visually adjust the mower deck side-to-side.
Note on the effect of adjustment nut turns on mower height.
How to test and readjust mower deck leveling.
A more precise method for adjusting mower deck side-to-side.
Instructions for adjusting the mower deck front-to-back.
Important prerequisite for front-to-back deck adjustment.
Caution about sharp mower blades during adjustment.
Note on the effect of adjustment nut turns on mower height.
Instructions for replacing the mower blade drive belt.
Steps to remove the mower drive belt.
Steps to install the mower drive belt.
Instructions for replacing the motion drive belt.
Steps to remove the motion drive belt.
Note on observing belt path and guides during removal.
Steps to install the motion drive belt.
How to check if the tractor's brake is functioning correctly.
How to adjust the transaxle motion control lever for neutral position.
Information on front wheel toe-in and camber (non-adjustable).
Instructions for removing a wheel for repair.
Note on using tire sealant for puncture prevention.
Procedure for starting the tractor with a weak battery using jumper cables.
Safety warning regarding explosive gases from lead-acid batteries.
Steps for correctly attaching jumper cables.
Steps for correctly removing jumper cables.
Instructions for replacing the tractor battery.
Warning about shorting battery terminals during replacement.
Instructions for removing the hood and grill assembly.
How to replace a headlight bulb.
Checking wiring related to interlocks and relays.
How to replace the tractor's fuse.
Information on transmission removal, replacement, and purging.
Engine adjustments.
How to adjust the throttle control cable.
How to adjust the choke control.
Information on carburetor adjustment or service.
Safety warning regarding storing tractors with fuel indoors.
Procedures for preparing the tractor for storage.
How to prepare the battery for storage.
Engine preparation for storage.
Important steps to prevent gum deposits in the fuel system during storage.
Note on using fuel stabilizer for storage.
How to prepare the engine oil for storage.
Steps to prepare the engine cylinders for storage.
Additional storage tips.
Troubleshooting steps for when the tractor will not start.
Troubleshooting steps for when the tractor is hard to start.
Troubleshooting steps when the engine does not turn over.
Troubleshooting steps when the engine clicks but won't start.
Troubleshooting steps for loss of power during operation.
Troubleshooting steps for excessive vibration.
Troubleshooting steps if the engine keeps running when operator leaves seat.
Troubleshooting steps for an uneven cut quality.
Troubleshooting steps if the mower blades are not rotating.
Troubleshooting steps for poor grass discharge.
Troubleshooting steps for non-working headlights.
Troubleshooting steps if the battery will not charge.
Troubleshooting steps for loss of drive.
Troubleshooting steps for engine backfiring when turned off.
Troubleshooting steps if the engine dies when shifting into reverse.
Key safety rule for operating on slopes.
Specifies the maximum allowable slope angle.
Critical warning about operating on slopes safely.
Instruction for preparing the slope guide.
Instruction for positioning the slope guide for measurement.
Instruction for sighting the slope direction.
Instruction for comparing the fold angle to the hill slope.
General statement of the manufacturer's warranty.
Exclusions from the main product warranty.
Responsibility for transportation charges related to warranty claims.
Specific warranty terms for the tractor battery.
Warranty period for rental or commercial use.
Conditions under which the warranty is valid.
Specific exclusions from warranty coverage.
Procedure for making a warranty claim.
Contact information for warranty questions.
Limitation of incidental or consequential damages in the warranty.
