Home
Power Flame
Burner
HAC3-GO2
Power Flame HAC3-GO2 User Manual
53 pages
Manual
Specs
Ask a question
To Next Page
To Next Page
Loading...
Power Flame Incorporated
HAC INSTALLATION
AND
OPERATION MANUAL
THE POWER TO MANAGE ENERGY
2001 South 21
st
Street, Parsons, Kansas 67357
T
elephone 620-421-0480, Fa
x
620-421-0948
W
eb Site:
www
.po
w
er
f
lame.com
E-Mail: csd@po
w
er
f
lame.com
HACOM 985
Rev. 0498
OBSOLETE
MODEL
2
Table of Contents
Table of Contents
3
General Product Information
5
Air Compressor
6
Model HAC Receiving Instructions
6
(Table 1) Standard Burner Ratings & Component Data
7
(Figure 1) Model HAC Dimensional Data
8
(Figure 2) Model HACR Dimensional Data
9
Installation Information General
10
Combustion Air Supply
11
Combustion Adjustments on Oil & Gas - General
11
Stack Temperature
11
Smoke Measurements
11
Gas Adjustments
11
Fuel Oil Adjustments
11
General Start-Up Procedures All Fuels
12
Fuel Oil Start-Up Procedures
13
Gas Fuel Start-Up Procedures
17
(Table 2) Combustion Chamber Dimension Chart
20
(Figure 3) Burner Mounting Detail for Brickset Firebox Boiler
21
(Figure 4) Burner Mounting Detail for Scotch Marine Boiler
22
(Figure 5) Burner Mounting Detail for Packaged Firebox Boiler
23
(Figure 6) No. 2 Fuel Oil Pump Suction Curve
24
(Figure 7) No. 4 Fuel Oil Pump Suction Curve
25
(Figure 8) No. 5 and 6 Fuel Oil Pump Suction Curve
26
(Figure 9) No. 2 Fuel - Oil/Air Piping Schematic
27
(Figure 10) No. 4 Fuel - Oil/Air Piping Schematic
28
(Figure 11) No. 5 and 6 - Oil/Air Piping Schematic
29
(Figure 12) Gas Piping Schematic - U.L. Gas Train
30
Compressed Atomizing Air Piping Information
31
(Table 3) Compressed Air Pipe Sizing
31
Gas Supply Piping
31
(Table 4A) Capacity of Pipe - Natural Gas
32
(Table 4B) Correction Factors
32
(Table 4C) Equivalent Length of Fittings in Feet
32
Adjusting and Servicing - General
33
Gas Pilot Ignition
33
Oil Pumps and Piping
34
Oil Nozzles
34
Electric Oil Heater
35
Air Compressor
35
(Figure 13) Internal Gas/Air Flow Drawing
36
(Figure 14) Linkage Adjustment - Gas/Oil
37
(Figure 15) Varicam Fuel Metering System
38
(Figure 16) Case Type - Gas Pilot Drawing
39
(Figure 17) Round Type - Gas Pilot Drawing
40
(Table 5) Oil/Air Pressure Chart
41
(Figure 18) CO Fuel Ratio Curve
41
(Figure 19) Fuel Oil Viscosity/Temperature Chart
42
Maintenance
43
Trouble Shooting Suggestions HAC Oil and Gas/Oil Burner
44
Gas Operation
45
Oil Operation
46
Burner Start-Up Information & Test Data
49
Owner Operating Instructions
52
Limited Warranty
53
Need help?
Do you have a question about the Power Flame HAC3-GO2 and is the answer not in the manual?
Ask a question
Power Flame HAC3-GO2 Specifications
General
Brand
Power Flame
Model
HAC3-GO2
Category
Burner
Language
English
Related product manuals
Power Flame C2-OA
55 pages
Power Flame C1-G-12
55 pages
Power Flame C3-G-25
55 pages
Power Flame C2-G-15
55 pages
Power Flame C1-GO-10
55 pages
Power Flame C5-GO-30
55 pages
Power Flame C2-GO-15
55 pages
Power Flame C Series
55 pages
Power Flame C2-GO-20A
55 pages
Power Flame C5-GO-30B
55 pages
Power Flame C3-GO-25B
55 pages
Power Flame C2-GO-20B
55 pages
Need help?
General
To Next Page