Premier RO-PURE Plus - Troubleshooting Common Issues; Low Production and Water Quality Problems; Unit Operation and Drain Issues

3DJH
TROUBLE SHOOTING
Problem Cause Solution
/RZ6ORZ3URGXFWLRQ /RZ:DWHU3UHVVXUH  $VVXUHDPLQLPXPRISVLLQFRPLQJZDWHUSUHVVXUH
Premier sells a booster pump if home water pressure is
low. Make sure water supply is turned on and feed water
valve is all the way open.
  &ULPSVLQWXELQJ  &KHFNWXELQJDQGVWUDLJKWHQRUUHSODFHDVQHFHVVDU\
  &ORJJHGSUH¿OWHUV  5HSODFHSUH¿OWHUV
  )RXOHGPHPEUDQH  5HSODFHPHPEUDQH
0LON\FRORUHG:DWHU  $LULQV\VWHP   $LULQWKHV\VWHPLVDQRUPDORFFXUUHQFHZLWKLQLWLDO 
start up of the RO system. This milky look will
GLVDSSHDUGXULQJQRUPDOXVHZLWKLQZHHNV,I 
FRQGLWLRQUHRFFXUVDIWHU¿OWHUFKDQJHGUDLQWDQNWR 
times.
:DWHUFRQVWDQWO\  /RZZDWHUSUHVVXUH  6HH$ERYH
running, unit will not
VKXWRII   &ULPSLQVXSSO\WXEH  &KHFNWXELQJDQGVWUDLJKWHQRUUHSDLUDVQHFHVVDU\
  +LJKZDWHUSUHVVXUH  &KHFNLQFRPLQJZDWHUSUHVVXUHWRPDNHVXUHLWGRHV 
QRWH[FHHGSVL$SUHVVXUHUHOLHIYDOYHPD\EH 
necessary.
  +LJKSUHVVXUHLQ7DQN  (PSW\VWRUDJHWDQNRIZDWHU6HWWDQNDLUSUHVVXUH 
EHWZHHQSVL6HHSUHYLRXVSDJH
  /RZ3UHVVXUHLQ7DQN  8VHD'LJLWDO$LU*DXJHIRUEHVWUHVXOWV7KHHPSW\
WDQNSUHVVXUHVKRXOGEHSVL6HHSDJH
:DWHUIURPIDXFHW&ULPSRUUHVWULFWLRQ  &KHFNWXELQJDQGVWUDLJKWHQRUUHSDLUDVQHFHVVDU\
YHQWKROHRUQRLVHIURP LQGUDLQOLQH  6WUDLJKWHQDOOGUDLQOLQHV&OHDUEORFNDJH&XWRIIDQ\
GUDLQ  ([FHVVWXELQJ
  'UDLQWXEHFORJJHG  &DXVHGIURPGLVKZDVKHURUJDUEDJHGLVSRVDO
'LVFRQQHFWWKH´EODFNOLQHDWWKHGUDLQFOHDQWKH 
´EODFNOLQHRXWZLWKDZLUHWKHQUHFRQQHFW%ORZLQJ 
air through the line will not always remove the clog.
6PDOODPRXQWRIZDWHULQ 6\VWHPVWDUWLQJXS  1RUPDOO\LWWDNHVKRXUVWR¿OOWDQN1RWHORZ
VWRUDJHWDQN  LQFRPLQJZDWHUSUHVVXUHDQGRUWHPSHUDWXUHFDQ 
drastically reduce production rate.
  /RZZDWHUSUHVVXUH  6HHDERYH
  7RRPXFKDLULQWDQN  7DQNDLUSUHVVXUHVKRXOGEHSVLZKHQHPSW\RIZDWHU
,IEHORZSVLDGGDLURUEOHHGLIDERYHSVL
&KHFNRQO\ZKHQWDQNLVHPSW\RIZDWHU
See previous page.
/RZZDWHUÀRZIURPIDXFHW &KHFNDLUSUHVVXUHLQWDQN 8VHD'LJLWDO$LU*DXJHIRUEHVWUHVXOWV7KHHPSW\ 
WDQNSUHVVXUHVKRXOGEHSVL6HHSDJH