Premier RO-PURE Plus - Drain Saddle Installation Process; Mounting the Drain Saddle; Connecting Drain Tubing

Page 9
'UDLQ6DGGOH¿WVVWDQGDUGó´±ò´GUDLQSLSHV
Drain Saddle Installation
6WHS
Step 8
Step 9
7KHGUDLQVDGGOHPXVWEHLQVWDOOHGDWOHDVWò´DERYHWKHQXW
of the P-Trap elbow or cross bar from the garbage disposal to
LQVXUHSURSHUGUDLQDJH8VLQJWKH´GULOOELWGULOOLQWRWKHGUDLQ
SLSHDWEHVWDYDLODEOHORFDWLRQDVVSHFL¿HGDERYHIRUGUDLQVDGGOH
installation. Take extreme caution to only drill through one side
of the drain pipe.
The small square black foam gasket with a circle cut out of the middle
must be applied to the inside of the drain saddle. Remove sticky tape
backing and stick to the drain saddle as shown.
1 Semicircle bracket with opening
6FUHZV)RDPJDVNHW
1XWVIRUVFUHZV   6HPLFLUFOHEUDFNHW
*DWKHUWKHSLHFHVRIWKHGUDLQVDGGOH
Caution:
Do not over tighten the screws. It may crack the drain saddle.
If you have a garbage disposal, do not install the drain saddle near it.
Installation of the drain saddle must be either above the garbage disposal, or
if a second sink drain is available, install it above the cross bar on the second
drain. Installation of the drain saddle near a garbage disposal may cause
the drain line to plug. If no other installation of drain line is available, Premier
offers drain line installation kit (part number 164020) that can be used with
garbage disposals.
Caution:
The black 3/8” drain tube must be as SHORT and STRAIGHT as possible to the drain
saddle, making a downward slope from faucet to drain saddle to allow for proper
drainage. This is a gravity fed line and if there is any bend or dip in the tube, the rinse
ZDWHUZLOOQRWÀRZLQWRWKHGUDLQSURSHUO\:DWHUPD\EDFNXSDQGFRPHRXWWKHDLU
gap hole in the back of the faucet.
IMPORTANT:
0HDVXUHWKH´EODFNWXEHIURPIDXFHWWRWKHGUDLQVDGGOHRQWKH
drain pipe and make a straight cut to the correct length.
&RQQHFWWKHEODFNWXEHWRWKHRSHQTXLFNFRQQHFW¿WWLQJRQWKHGUDLQ
saddle by pushing the tube all the way to the tube stop.
6WHS
Step 11
$VVHPEOHWKHGUDLQVDGGOHDURXQGWKHGUDLQSLSHDQGDOLJQGUDLQ
VDGGOH¿WWLQJRSHQLQJZLWKWKHKROHGULOOHGLQWKHSUHYLRXV
step - you may use a small screwdriver to feed through the drain
VDGGOHLQWRWKHGUDLQSLSHWRDLGZLWKWKHDOLJQPHQW8VLQJD3KLOOLSV
screw driver tighten the drain saddle bolts evenly and securely on
both sides.
Step 10