C120R Operator Service Maintenance Manual
800.392.2686
49
Rear Radiator Screen - Clean
The rear radiator screen (4) should be cleaned frequently to
guard against overheating. To access, open the rear door
and swing the winch out of the way. Remove and clean
as necessary using compressed air or a pressure washer.
Replace screen if damaged.
Engine Coolant Hose & Pressure
Cap - Check
Check for damaged hoses, pipes and loose or damaged
hose clamps. Replace as required. Check radiator for any
sign of leaks, damage and buildup of dirt or debris. Clean and
replace as needed. Check the radiator pressure cap and seal.
Engine Coolant Anti-Freeze - Check
Use a refractometer to achieve the most accurate reading.
Refer to pg. 36 of this manual for proper dilution.
Engine Crankcase Breather Tube -
Inspect
Consult your Engine Manual for details.
Engine Injectors - Inspect
Consult your Engine Manual for details.
Engine Leaks - Check
Check for leaks as described in the Engine Operation Manual.
Engine Mounts - Check
Check and tighten if necessary all engine mounts.
Engine Oil Level - Check
NOTICE
Always check coolant level while machine is parked
on level ground. Overfilling radiator could result in
coolant leaking. Always add a pre-mixed solution
rather than undiluted antifreeze to the radiator. If
pure water must be added in an emergency, the
entire cooling system must be drained and flushed,
as soon as possible, to prevent damage to the
engine.
Maintenance
4
To Next Page
Loading...
Need help?
General
