red lion RL160U - User Manual

200567e 0902
OWNER'S
MANUAL
SUBMERSIBLE
UTILITY PUMP
RL160U
APPLICATION
This pump is suitable for portable applications where
the total head requirement (including pipe friction
losses) does not exceed the pump's maximum capabil-
ity. Also, the maximum solids size must not be greater
PRINTED IN
TAIWAN
BEFORE OPERATING OR
INSTALLING THIS PUMP,
READ THIS MANUAL AND
FOLLOW ALL SAFETY
RULES AND OPERATING
INSTRUCTIONS.
WARNING - ELECTRICAL PRECAUTIONS
All wiring, electrical connections, and system ground-
ing must comply with the National Electrical Code
(NEC) and with any local codes and ordinances. Em-
ploy a licensed electrician.
WARNING - RISK OF ELECTRICAL SHOCK
• Have an electrician provide electrical power to the
motor plug receptacle.
• Always disconnect plug from power source before
handling.
• This product is furnished with a three prong plug for
grounding, connect only to properly grounded recep-
tacle.
SAFETY
CAREFULLY READ THESE SAFETY
MESSAGES IN THIS MANUAL AND ON
PUMP.
CAUTION
• Review instructions before operating.
SAFETY WARNINGS
• Do not under any circumstances remove ground plug.
• Keep electric plug dry.
• Do not lift pump using cord.
• Not investigated for use in swimming pool area.
• A ground fault interrupter (GFI) protected circuit is
recommended for use with any electrical appliance
operating in or near water.
than the pump capability. This pump is for use with
water only, NOT FOR USE IN EFFLUENT OR SEW-
AGE APPLICATIONS!
RL160U

Summary

Safety Warnings

Electrical Precautions

All wiring, electrical connections, and system grounding must comply with the National Electrical Code (NEC) and local codes. Employ a licensed electrician.

Risk of Electrical Shock

Have an electrician provide electrical power. Always disconnect plug before handling. Connect only to properly grounded receptacle.

Application

Installation

Location

Pump should be on a solid level foundation. Do not suspend by cord or pipe. Keep inlet screen clear.

Electrical Risk

Connect to grounded outlet. GFI recommended. Requires 15 amp, 115 volt AC circuit within 8 feet of pump.

Discharge Piping - Rigid Pipe

Use threaded opening. Adapt to other sizes if needed. Do not reduce pipe size. Keep piping length minimal.

Discharge Piping - Garden Hose

Thread garden hose adapter into pump. Attach hose; shorter lengths allow better flow.

Air Locking

Maintenance

Troubleshooting Guide

Safety Tips

red lion RL160U Specifications

General

Horsepower	1.5 HP
Maximum flow rate	160 GPM
Voltage	115/230V
Inlet size	1.5 inches
Outlet size	1.5 inches
Maximum water temperature	140°F
Motor type	TEFC
Amperage	16/8 A