EasyManua.ls Logo

RevoAce GBC1793W - User Manual

RevoAce GBC1793W
25 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
OWNER’S MANUAL
Outdoor LP Gas / Charcoal Barbecue Grill
Model No. GBC1793W
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only! (outside any enclosure)
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance, immediately call your
gas supplier or your fire department.
Failure to follow these instructions
could result in fire or explosion
which could cause property damage,
personal injury or death.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
1.800.694.0013 • service@revoace.com
8:00 am to 4:00 pm central time, Monday to Friday.
DANGER
Never operate this appliance
unattended.
GBC1793W-OM-E-F101
WARNING
CALIFONIA PROPOSITION 65
This product can expose you to
chemicals including benzene, which
is known to the State of California to
cause cancer. For more information,
go to www.P65Warnings.ca.gov.
Important Safeguard
s ....................
Page 2
Expanded View & Hardware ................ 6 & 7
Assembly Instructions........................ 9
Installing LP Gas Tank....................... 16
Operating Instructions....................... 17
Cleaning and Care ......................... 21
Limited Warranty ...........................23
Troubleshooting ........................... 24
The use and installation must conform with local codes or,
in the absence of local codes, with either the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane
Installation Code, CSA B149.1, or Propane Storage and
Handling Code, B149.2, or the Standard for Recreational
Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV
Series, Recreational Vehicle Code, as applicable.
This instruction booklet contains important safety
information. Please read and keep for future reference.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
California Proposition 65: Handling the brass material
on this product exposes you to lead, a chemical known
to the State of California to cause cancer, and birth
defects or other reproductive harm. Wash your hands
after handling this product.
Table of Contents

Table of Contents

Questions and Answers

  • B
    brianhansenAug 14, 2025
    What to do if my RevoAce GBC1793W burner will not light using igniter?
    • M
      Matthew BurchAug 14, 2025
      If the burner on your RevoAce Grill won't light with the igniter, several factors could be at play. First, ensure the LP gas tank valve is open and the regulator is securely attached. If the tank is low or empty, exchange, refill, or replace it. Check for cooking residue on the wires or electrode and clean them with rubbing alcohol if necessary. Also, wipe dry the electrode and burners if they are wet. For cracked/broken electrodes, loose or disconnected wires, shorting wires, or a bad igniter, replacement parts may be needed, and Customer Care should be contacted.
  • O
    orayAug 17, 2025
    Why is there no gas flow to my RevoAce GBC1793W?
    • H
      hooperpaigeAug 17, 2025
      If there's no gas flow to your RevoAce Grill, start by checking if the LP gas tank is empty and exchange, refill, or replace if needed. Ensure the coupling nut and regulator are fully connected by hand-tightening until a solid stop. Also, clear any obstruction of gas flow in the burner/venturi tube and check for bent or kinked hoses. Reengage the burner to the valve if disengaged. Finally, clean the burner/venturi tube to remove any spider webs or insect nests, and clean any clogged or blocked burner ports.
  • T
    Tristan WilsonAug 21, 2025
    What causes flare-ups on a RevoAce GBC1793W Grill?
    • L
      Linda AndersonAug 21, 2025
      Flare-ups on your RevoAce Grill can occur due to excess fat in the meat. Trim the fat from the meat before grilling to help prevent this. Also, excessive cooking temperature can cause flare-ups, so adjust to a lower cooking temperature.
  • M
    Michael SharpAug 25, 2025
    What to do if my RevoAce GBC1793W Grill is out of gas?
    • M
      Michael WilsonAug 25, 2025
      To address your RevoAce Grill running out of gas, exchange, refill, or replace the LP gas tank. Additionally, the overfilling prevention device may have been activated. To resolve this: 1. Turn control knobs to “ OFF”. 2. Wait 30 seconds and light grill. 3. If flames are still too low, reset the overfilling prevention device by: a. Turning control knob(s) “ OFF”. b. Turning LP gas tank valve to “CLOSED”. c. Disconnecting the regulator. d. Turning control knobs to (HIGH). e. Waiting 1 minute. f. Turning control knobs to “ OFF”. g. Reconnecting the regulator and leak-checking connections, being careful not to fully open the valve. h. Lighting the grill.
  • S
    Sharon HobbsAug 27, 2025
    What causes a persistent grease fire in my RevoAce GBC1793W Grill?
    • C
      Cathy FigueroaAug 27, 2025
      A persistent grease fire in your RevoAce Grill is often caused by grease trapped by food buildup around the burner system. To address this: 1. Turn control knobs to “ OFF”. 2. Turn LP gas tank valve to “CLOSED”. 3. Leave lid in closed position and let fire burn out. 4. After grill cools, remove and clean all parts.
  • M
    martinkatherineAug 31, 2025
    How to fix irregular flame pattern on RevoAce Grill?
    • E
      ejacksonAug 31, 2025
      An irregular flame pattern on your RevoAce Grill, where the flame doesn't run the full length of the burner, is often due to clogged or blocked burner ports. Cleaning the burner ports should resolve this issue.
  • K
    Kristen KingSep 3, 2025
    Why is the flame yellow or orange on my RevoAce GBC1793W Grill?
    • J
      Justin ArmstrongSep 3, 2025
      A yellow or orange flame on your RevoAce Grill can be due to several reasons. If it's a new burner, it may have residual manufacturing oils; burn the grill for 15 minutes on high with the lid closed. Spider webs or insect nests in the venturi can also cause this, so clean the venturi. Additionally, food residue or grease on the burners, or poor alignment of the valve to the burner/venturi tube can be responsible. Clean the burner and ensure the burner/venturi tube is properly engaged with the valve.
  • R
    rodriguezandrewSep 6, 2025
    What causes flashback (fire in burner tube(s)) in RevoAce GBC1793W?
    • S
      saragriffithSep 6, 2025
      Flashback, or fire in the burner tubes of your RevoAce Grill, is caused by blocked burners and/or burner/venturi tubes. Clean the burners and/or burner/venturi tube to resolve this issue.
  • S
    Steven DuranSep 10, 2025
    Why is the inside of my RevoAce GBC1793W lid peeling?
    • W
      William AguirreSep 10, 2025
      The peeling on the inside of your RevoAce Grill lid is likely due to baked-on grease buildup that has turned to carbon and is flaking off. Clean all grill parts to resolve this.

Summary

Safety Warnings and Precautions

Gas Leak Danger and Response

If you smell gas - Shut off gas to appliance. Extinguish any open flame. Open lid. If odor continues, keep away from the appliance...

Important Safeguards

Grill Placement and Usage Restrictions

This grill is for outdoor use only, and should not be used in a building, garage or any other enclosed area. Do NOT operate, light or use this appliance within ten feet...

Fuel and Cylinder Safety Guidelines

Propane: The “gas” side of the grill, from the factory, is for use with liquid propane (LP) gas only. Charcoal: Never use charcoal that has been pre-treated... LP gas characteristics: LP gas is flammable...

LP Gas Cylinder and Leak Safety

Cylinder Handling and Storage

LP gas cylinder must be arranged for vapor withdrawal. The LP gas cylinder must have a listed overfilling prevention device (OPD)... LP gas cylinders must be stored outdoors...

Valve and Connection Safety

Do NOT insert any tool or foreign object into the valve outlet or safety relief valve. Never keep an LP gas cylinder in a hot car or trunk...

Leak Testing Procedures

Your grill has been checked at all factory connections for leaks. Recheck all connections... Do NOT operate if a gas leak is present...

Grill Operation and Maintenance Safety

Usage Restrictions and Fire Safety

Do NOT alter grill in any manner... Do NOT build this model of grill in any built-in or slide-in construction... When cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do NOT attempt to extinguish with water.

Grill Usage and Maintenance Precautions

Burner Lighting and Operation Safety

Always open grill lid carefully and slowly... Failure to open lid while igniting the grill's burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flare-up.

Assembly Instructions

Attaching Lid Handles, Gauges, and Hinges

Step 2: Attach Lid Handles, Temperature Gauges and Top Hinges. Shows hardware and placement for these components.

Assembling Main Body Panels

Assembly Steps

Attaching Manifold, Regulator, and Panels

Attaching Receiver Tray Support and Legs

Attaching Bottom Rack and Hinges

Attaching Pan Handle, Vent, and Lighting Rod

Attaching Gas Valve and Lids

Attaching Tray Handles and Shelves

Installing Heat Shields and Side Panels

Attaching Bottom Shelf and Wheels

Attaching Charcoal Pan and Components

Installing Burners and Igniter Wires

Installing Side Burner and Tank Retainer

Installing Grease Cup and Warming Racks

Attaching Side Shelves and Tool Holders

Installing LP Gas Tank

LP Gas Tank Installation Procedure

To operate, you will need one precision-filled standard grill LP gas tank... Place precision-filled LP gas tank upright into the notches...

LP Gas Tank Connection and Leak Check

Connecting, Disconnecting, and Leak Testing

Connect regulator/hose assembly to tank... Make sure connections are secure. Spoon drops of leak detection solution at connection points.

Initial Setup and Burner Connections

Operating Main Burners

Lighting Procedure and Safety

Open lid, check for obstructions. Turn knobs to OFF. Connect tank, turn valve OPEN. Push knob to HIGH to light burner. Use lighting rod if needed.

Shutting Down and Flare-up Control

Side Burner Operation

Side Burner Lighting and Safety

Open lid, check for obstructions. Turn knob to OFF. Connect tank, turn valve OPEN. Push knob to HIGH to light burner. Use lighting rod if needed.

Side Burner Cooking and Shutdown

Operating Charcoal Grill

Charcoal First Use and Lighting

Charcoal Lighting Safety and Procedure

Keep area clear. Check air vents. Attempting to light with lid closed may cause explosion. Arrange charcoal to the 'Fill Line'.

Charcoal Grill Shutdown and Flare-ups

Cleaning and Care

General Cleaning and Maintenance Precautions

Side Burner Cleaning and Inspection

Main Burner Cleaning and Inspection

Troubleshooting Guide

Burner Ignition Issues

Problem: Burner will not light using igniter. Possible Cause: Wires or electrode covered with cooking residue, bad igniter.

Flame Out and Flare-up Issues

Problem: Flame goes out. Possible Cause: High or gusting winds, Low on LP Gas. Problem: Flare-up. Cause: Grease buildup, Excess fat in meat.

Flame Output and Gas Flow Problems

Problem: Burner will not light with match. Possible Cause: Coupling nut and regulator not fully connected. Problem: Sudden drop in gas flow or reduced flame height.

Grease Fires and Flashbacks

Problem: Persistent grease fire. Cause: Grease trapped by food buildup. Problem: Flashback (fire in burner tube(s)). Cause: Burner and/or burner/venturi tube are blocked.

Flame Pattern and Color Issues

Lid Peeling and Burner Maintenance

RevoAce GBC1793W Specifications

General IconGeneral
BrandRevoAce
ModelGBC1793W
CategoryGrill
LanguageEnglish

Related product manuals