Rheem Water Heater - Typical Installation - Outdoor Location

Rheem Water Heater

63 pages

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

INSTALLATION – SOLAR STORAGE TANK

34

TYPICAL INSTALLATION – OUTDOOR LOCATION

Table of Contents

Owners Guide1
Installation Instructions1
Warning: Plumber – be Aware2
Table of Contents3
Solar Controller and Solar Monitor4
Commissioning5
Diagnostic Features of the Solar Controller6
About Your Water Heater7
- Model Type7
- How Hot Should the Water be7
- Temperature Adjustment8
- Safety9
- How Do I Know if the Water Heater Is Installed Correctly10
- To Turn on the Water Heater10
- To Turn off the Water Heater10
- Pipe Work and Insulation11
- Does the Water Quality Affect the Water Heater?11
- How Long will the Water Heater Last?11
- Anode Protection11
- Bleeding the Solar Collectors12
- To Purge Air from the Collector Circuit12
- Freeze Protection13
- Mains Pressure14
- Gas Boosting14
How Your Water Heater Works14
- Going on Holidays15
- Piezo Ignition15
- Pilot Igniter15
- Temperature Pressure Relief Valve16
Regular Care16
- Expansion Control Valve17
- Servicing17
- Collector Glass17
- Flushing the Solar Collectors18
Timer Operation19
- Battery Backup20
- Recommended Timer On/Off Setting20
- Reset the Timer20
- To Set the Time21
- To Set On/Off Times21
- Manual Boosting - "Override" Function23
- Caution - "Random" Function23
- Not Enough Hot Water (or no Hot Water)24
Save a Service Call24
- Water Not Hot Enough25
- Temperature Pressure Relief Valve Running26
- Expansion Control Valve Running26
- Timer Appears to be Functioning Incorrectly27
- Can't Light the Pilot Flame27
- Water Heater Appears to be Leaking27
- High Gas Bills28
- Solar Water Heater Storage Tank Location29
Installation - Solar Storage Tank29
- Mains Water Supply31
- Tank Water Supply31
- Hot Water Delivery32
- Two Temperature Zones Using a Temperature Limiting Device - Diagram32
- Circulated Hot Water Flow and Return System33
- Temperature Limiting Device33
- Reducing Heat Losses34
- Circulated Hot Water Flow and Return System – Solar Water Heater - Diagram34
- Saddling - Pipe Work35
- Anode Types35
- Dimensions and Technical Data36
- Typical Installation - Outdoor Location37
- Assembly of Solar Hot and Solar Cold Pipe Connections38
- Solar Collector Location39
Installation - Solar Collectors39
- Latitude of some Australian Cities40
- Pipe Lenghts40
- Maximum Height to Collectors40
- Plumber – be Aware (Warning)41
Connections - Plumbing42
- Pipe Sizes43
- Relief Valve Drain44
- Relief Valve44
- Expansion Control Valve (ECV)45
- Gas Inlet45
- Bleed Valve Drain45
Connections - Electrical46
- The Power Consumption of the Water Heater47
- Wiring Diagrams47
- To Fill and Turn on the Water Heater48
Commissioning48
- Gas Inlet Pressure49
- To Bleed the Solar Collectors49
- Turning off the Water Heater50
- Before Lighting: Safety Information51
Lighting the Water Heater51
- Lighting Instructions52
- Test the Water Heater after Installation53
- Air Shutter53
- Close down Procedure54
Draining the Solar Collectors55
Draining the Water Heater56
Anode59
Water Supplies59
Saturation Index60
Warranty61
Warranty Exclusions62

Related product manuals

Rheem ELECTRIC WATER HEATERS

Preview: Rheem Solar Loline Water Heater

Rheem Solar Loline Water Heater

Preview: Electric Domestic Water Heater

Electric Domestic Water Heater

Preview: RUUD Commercial Water Heaters

RUUD Commercial Water Heaters

Preview: Gas Domestic Indoor Water Heater

Gas Domestic Indoor Water Heater

Preview: PowerVent Commercial Gas Water Heater

PowerVent Commercial Gas Water Heater

Preview: Gas Heavy Duty Water Heater Models 265 Litre and 275 Litre

Gas Heavy Duty Water Heater Models 265 Litre and 275 Litre

Preview: Rheem 18

Preview: Rheem 65

Preview: Rheem 120

Preview: Rheem TRITON

Preview: Rheem Stellar