ENGLISH
(
US
)
(e) MAINTENANCE STATEMENTS
It is your responsibility to have all scheduled inspection and maintenance services
performed at the times recommended in the 2007 and later Owner's Manual and to retain
proof that inspection and maintenance services are performed at the times when
recommended. FUJI HEAVY INDUSTRIES LTD. will not deny a warranty claim solely
because you have no record of maintenance; however, FUJI HEAVY INDUSTRIES LTD.
may deny a warranty claim if your failure to perform required maintenance resulted in the
failure of warranted part. The proof, which you maintain, should be given to each
subsequent owner of the engine. You are responsible for performing the scheduled
maintenance described below based on the procedures specified in the 2007 and later
Owner's Manual. The scheduled maintenance below is based on the normal engine-
operating schedule.
PROCEDURE INTERVAL
1) Clean engine and check bolts and nuts. :Every 8 hours(daily)
Retighten if necessary.
2) Check and refill engine oil :Every 8 hours
(4stroke engine only) (refill daily up to upper limit)
3) Change engine oil :Initial 20 hours and every
(4stroke engine only) 50 hours afterward
4) Check clogging of cooling air passage and :Every 8 hours (daily)
cylinder fins. Remove and clean if necessary.
5) Clean air cleaner. :Every 8 hours (daily)
6) Check spark plug. :Every 8 hours (daily)
Clean and adjust if necessary.
7) Check muffler exhaust outlet(or port). :Every 50 hours (monthly)
Clean if necessary.
8) Check fuel filter. If clogged, replace with :Every 50 hours (monthly)
new one.
9) Adjust valve clearance, if applicable :Every 200 hours (yearly)
(4stroke engine only).
10) Replace fuel lines. :Every 200 hours (yearly)
11) Clean and inspect the complete engine. :Every 200 hours
Replace any damaged or worn out parts.
12) Replace packings and gaskets with new ones. :Every reassembling
WS2301
To Next Page
Loading...
Need help?
General
