EasyManua.ls Logo

Rolair D2002HPV5 - User Manual

Rolair D2002HPV5
47 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
- 1 -
PORTABLE AIR COMPRESSOR
MANUEL PAGE 16
MANUAL DE INSTRUCCIONES ESPAÑOLES PÁGINA 31
MODEL: D2002HPV5
SERIAL NUMBER: __________________
606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com

Table of Contents

Questions and Answers

  • V
    vphillipsJul 28, 2025
    Why is my Rolair D2002HPV5 Air Compressor pump slow to build tank pressure?
    • W
      wjohnsonJul 28, 2025
      A slow-building tank pressure in your Rolair Air Compressor can stem from several issues: * A loose or slipping belt: adjust the belt tension. * Excessive leaks in the system: correct any air leaks. * A blown gasket: replace the head gaskets. * A broken reed valve: replace the reed valves. * An obstructed intake filter: clean or replace the intake element. * A leaking regulator: replace the regulator. * A defective pilot valve: replace the pilot valve.
  • C
    Charles LewisAug 1, 2025
    What to do if my Rolair D2002HPV5 Air Compressor motor trips the overload/reset button?
    • A
      Arthur DanielsAug 1, 2025
      If the motor trips the overload/reset button, it might be due to several reasons: * The motor is starting and stopping too often: consider installing a constant speed or dual control kit. * The overload is defective or weak: replace the overload. * Improper gauge of extension cord: use longer lengths of air hose or a heavier cord. * Stripped or poorly tightened motor thru bolts: retighten or replace the stripped thru bolts. * Cracks in the end bell or housing: take the unit in for service.
  • M
    Melissa BlairAug 5, 2025
    What to do if my Rolair Air Compressor electric motor is dead and won't hum?
    • C
      Cassidy PageAug 5, 2025
      If your Rolair Air Compressor's electric motor is dead and doesn't even hum, check for these potential causes: * The thermal overload tripped: locate and push the reset button. * The reset is physically broken: replace the overload/reset. * Loose motor leads or electrical connections: locate and correct any loose electrical connections. * A short in the power cord: replace the power cord.
  • A
    Andrew DanielsAug 9, 2025
    Why does my Rolair D2002HPV5 have excessive oil consumption?
    • C
      Carolyn MartinezAug 9, 2025
      Excessive oil consumption in your Rolair Air Compressor might be caused by: * Too much oil in the crankcase: drain it to the proper level. * Improper weight of oil: replace it with the proper oil. * An obstructed crankcase vent: replace the dipstick or oil fill plug/crankcase vent. * Dirty or plugged intake filter: clean or replace the intake filter. * Worn piston rings or a scored cylinder: take the unit in for service.
  • J
    Johnny TuckerAug 14, 2025
    What to do if my Rolair Air Compressor is overheating?
    • S
      stevengonzalezAug 14, 2025
      If your Rolair Air Compressor is overheating, consider the following: * Poor ventilation: relocate the compressor to a better-ventilated area. * Improper pump rotation: contact an electrician. * Internal pump problem: take the unit in for service.
  • J
    Jesse WatsonAug 18, 2025
    Why is my Rolair D2002HPV5 Air Compressor gasoline engine hard to start?
    • M
      michael43Aug 18, 2025
      If the gasoline engine of your Rolair Air Compressor is hard to start, it could be due to: * A fouled, incorrect, or improperly gapped spark plug: install the proper spark plug after gapping it to factory specifications. * Improper engine oil level: fill to the top of the threads for the oil plug. * Improper weight of pump or engine oil: change to the proper weight of oil for the operating temperature. * Improper or old gas: take the unit in for service.
  • S
    Scott MurrayAug 22, 2025
    What causes a knocking noise in my Rolair D2002HPV5?
    • J
      jessicabrewerAug 22, 2025
      A knocking noise in your Rolair Air Compressor could be due to: * A loose pulley or flywheel: tighten the appropriate parts. * Loose belts: adjust the belt tension. * An internal pump problem: take the unit in for service.

Rolair D2002HPV5 Specifications

General IconGeneral
BrandRolair
ModelD2002HPV5
CategoryAir Compressor
LanguageEnglish

Related product manuals