Sanyo DWM-4500 - TV Connection Types

- 13 -
CAUTION : Regular type resistors and capacitors are not listed. To know those values, refer to the schematic diagram.
Regular type resistors are less than 1/4 W carbon type and 0 ohm chip resistors.
Regular type capacitors are less than 50 V and less than 1000 µF type of Ceramic type and Electrical type.
N.S.P : Not available as service parts.
PRODUCT SAFETY NOTICE
EACH PRECAUTION IN THIS MANUAL SHOULD BE FOLLOWED DURING SERVICING. COMPONENTS IDENTIFIED WITH THE IEC
SYMBOL
!
!!
IN THE PARTS LIST AND THE SCHEMATIC DIAGRAM DESIGNATED COMPONENTS IN WHICH SAFETY AND
PERFORMANCE CAN BE OF SPECIAL SIGNIFICANCE. WHEN REPLACING A COMPONENT IDENTIFIED BY
!
!!
, USE ONLY THE
REPLACEMENT PARTS DESIGNATED, OR PARTS WITH THE SAME RATINGS OF RESISTANCE, WATTAGE OR VOLTAGE THAT ARE
DESIGNATED IN THE PARTS LIST IN THIS MANUAL. LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS MUST BE MADE TO
DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT BEFORE RETURNING THE
PRODUCT TO THE CUSTOMER.
REF.NO. PART NO. DESCRIPTION
PARTS LIST
REAR SPEAKAER PACKING
REF.NO. PART NO. DESCRIPTION
614 333 7331 CUSHION,LEFT,REAR SP
614 333 7348 CUSHION,RIGHT,REAR SP
614 188 3793 INSPECTION SHEET
645 075 2315 POLY SHEET-0150X0150*NC,
ANTENNA
645 065 8846 POLY SHEET-0650X0650*NC
REAR SPEAKER CABINET & CHASSIS
REF.NO. PART NO. DESCRIPTION
1 614 332 8216 ASSY,CABINET,TOP
4 614 332 8292 ASSY,NET,LEFT(US)
4 614 333 8543 ASSY,NET,LEFT(CA)
5 614 332 8308 ASSY,NET,RIGHT(US)
5 614 333 8550 ASSY,NET,RIGHT(CA)
8 614 332 8254 ASSY,CABINET,BOTTOM
10 614 332 3310 COVER,SWITCH
11 614 332 1804 MOUNTING,SP,LEFT
12 614 332 1811 MOUNTING,SP,RIGHT
13 614 332 1781 HOLDER,POWER,TRANS
14 614 332 1842 SHIELD,AMP,PWB
15 614 332 1798 MOUNTING,AMP,PWB
16 614 333 5160 ASSY,PANEL REAR(CA)
16 614 332 1828 PANEL,REAR(US)
REAR SPEAKER FIXING PARTS
REF.NO. PART NO. DESCRIPTION
Y02 411 021 3404 SCR S-TPG BIN 3X10,
CABINET TOP-GRILLE
Y05 411 021 3404 SCR S-TPG BIN 3X10
Y06 411 098 0801 SCR S-TPG BIN 3X14,
CABINET TOP-CABINET BOTT
Y07 411 098 0801 SCR S-TPG BIN 3X14,
CABINET BOTTOM-MOUNTING
Y08 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM- PWB DG
Y09 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM- PWB LED
Y10 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM- PWB DG
Y11 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM- PWB ANNT
Y12 411 193 8603 SCR S-TPG BRZ+FLG 3X10,
SPEAKER-MG SPEAKR
Y13 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM-MG SPEAKR
Y14 411 027 3507 SCR S-TPG BIN 4X6,HOLDER P.T-P.T
Y15 411 021 7204 SCR S-TPG BIN 4X10,
CABINET BOTTOM-HOLDER P.
Y16 411 098 4205 SCR S-TPG BIN 3X8,
SHIELD-MOUNTING PWB AMP
Y17 411 098 4205 SCR S-TPG BIN 3X8,
PWB AMP-MOUNTING PWB AM
Y18 411 021 3404 SCR S-TPG BIN 3X10,
CABINET BOTTOM-MOUNTING
Y19 411 123 9106 SCR S-TPG BIN 3X20,P.REAR
(BOTTOM)
Y20 411 021 3404 SCR S-TPG BIN 3X10,P.REAR
(BOTTOM)
Y21 411 098 0801 SCR S-TPG BIN 3X14,P.REAR
Y22 411 021 3404 SCR S-TPG BIN 3X10,P.REAR -ELEC
REAR SPEAKER ELECTRICAL-PARTS
REF.NO. PART NO. DESCRIPTION
9 645 051 0656 CORE,FERRITE,FOR DG-MAIN
or 645 042 8999 CORE,FERRITE,FOR DG-MAIN
51
!
!!
423 027 4903 FUSE 125V 2A
52
!
!!
645 066 9965 CORD,POWER-1.76MK
53 645 071 5518 ANTENNA,ROD
54 645 072 7504 SPEAKER,4
or 645 076 7210 SPEAKER,4
56
!
!!
645 072 1526 TRANS,POWER
57 614 332 1927 ASSY,WIRE RX-DG
58 614 332 1934 ASSY,WIRE
59 614 332 1958 ASSY,WIRE,LCH
60 614 332 9947 ASSY,WIRE,RCH
74 645 071 4559 UNIT,WIRELESS RECEIVER
645 051 0656 CORE,FERRITE
645 042 8999 CORE,FERRITE
REAR SPEAKER POWER SW P.W.BOARD ASSY
REF.NO. PART NO. DESCRIPTION
71 614 332 8117 ASSY,PWB,SW,POWER SW(Only initial)
C3900
!
!!
403 349 3303 CERAMIC 0.01U M 250V
or
!
!!
403 366 7803 CERAMIC 0.01U M 250V
C3901
!
!!
404 088 7409 MT-POLYEST 0.1U K 250V
or
!
!!
404 080 8206 MT-POLYEST 0.1U K 250V
or
!
!!
403 376 2409 MT-POLYEST 0.1U M 250V
CN390
!
!!
645 005 9315 PLUG,2P
FPC01 645 006 4760 HOLDER,FUSE
or 645 031 7903 HOLDER,FUSE
FPC02 645 006 4760 HOLDER,FUSE
or 645 031 7903 HOLDER,FUSE
L3900
!
!!
645 038 7364 INDUCTOR,70U
R3900
!
!!
402 087 3408 RESISTOR 3.3M J- 1/2W
or
!
!!
402 099 6206 RESISTOR 3.3M J- 1/2W
or
!
!!
402 078 9501 CARBON 3.3M J- 1/2W
or
!
!!
402 078 8108 CARBON 3.3M J- 1/2W
S3900
!
!!
645 072 1496 SWITCH,PUSH POWER
WR390
!
!!
614 017 6964 TERMINAL BOARD
WR391
!
!!
614 017 6964 TERMINAL BOARD
REAR SPEAKER LED P.W.BOARD ASSY
REF.NO. PART NO. DESCRIPTION
72 614 332 1583 ASSY,PWB,LED(Only initial)
CN370 614 035 4911 SOCKET,DIP 2P
CN372 614 332 1941 ASSY,WIRE
D3700 407 245 2309 LED SMLA12BC4T