Sanyo DWM-4500 - Before Operation; Common Operation

- 17 -
PARTS LIST
CAUTION : Regular type resistors and capacitors are not listed. To know those values, refer to the schematic diagram.
Regular type resistors are less than 1/4 W carbon type and 0 ohm chip resistors.
Regular type capacitors are less than 50 V and less than 1000 µF type of Ceramic type and Electrical type.
N.S.P : Not available as service parts.
PRODUCT SAFETY NOTICE
EACH PRECAUTION IN THIS MANUAL SHOULD BE FOLLOWED DURING SERVICING. COMPONENTS IDENTIFIED WITH THE IEC
SYMBOL
!
!!
IN THE PARTS LIST AND THE SCHEMATIC DIAGRAM DESIGNATED COMPONENTS IN WHICH SAFETY AND
PERFORMANCE CAN BE OF SPECIAL SIGNIFICANCE. WHEN REPLACING A COMPONENT IDENTIFIED BY
!
!!
, USE ONLY THE
REPLACEMENT PARTS DESIGNATED, OR PARTS WITH THE SAME RATINGS OF RESISTANCE, WATTAGE OR VOLTAGE THAT ARE
DESIGNATED IN THE PARTS LIST IN THIS MANUAL. LEAKAGE-CURRENT OR RESISTANCE MEASUREMENTS MUST BE MADE TO
DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT BEFORE RETURNING THE
PRODUCT TO THE CUSTOMER.
SUBWOOFER SPEAKER PACKING
REF.NO. PART NO. DESCRIPTION
614 332 3778 CUSHION,BOTTOM
614 332 3761 CUSHION,TOP
645 056 9173 POLY BAG-0150X0200*NC,AC CODE
645 075 2315 POLY SHEET-0150X0150*NC,
ANTENNA
645 073 9651 POLY SHEET-1200X0600*NC,WOOFER
SUBWOOFER SPEAKER CABINET & CHASSIS
REF.NO. PART NO. DESCRIPTION
1 614 333 0530 ASSY,BOX,SPEAKER
2 614 331 3519 HOLDER,POWER,TRANS
3 614 331 3526 MOUNTING,AMP,PWB
4 614 331 3601 SHIELD,AMP,PWB
5 614 327 8498 HOLDER,PWB,DG PWB
7 614 333 1872 SHIELD,REAR(CA)
7 614 333 0561 SHIELD,REAR(US)
9 614 333 0554 PANEL,REAR
10 614 332 2108 HOLDER,PWB,TRANSMITTER
11 614 332 2115 HOLDER,PWB,SWITCH
SUBWOOFER SPEAKER FIXING PARTS
REF.NO. PART NO. DESCRIPTION
Y01 411 191 4607 SCR S-TPG BIN 4X16,
HOLDER P.T-SP.BOX
Y02 411 027 3507 SCR S-TPG BIN 4X6,HOLDER P.T-P.T
Y04 411 098 4205 SCR S-TPG BIN 3X8,
AMP PWB-MOUNTING
Y05 411 098 4205 SCR S-TPG BIN 3X8,
SHIELD-MOUNTING AMP PWB
Y07 411 098 4205 SCR S-TPG BIN 3X8,
DG PWB-HOLDER PWB
Y08 411 021 3404 SCR S-TPG BIN 3X10,
PANEL REAR-SHIELD REAR
Y09 411 021 2605 SCR S-TPG BIN 2.6X6,SYSTEM
Y10 411 021 3404 SCR S-TPG BIN 3X10,
E.PARTS-P.REAR
Y12 411 193 7705 SCR S-TPG BIN 3X16,P.REAR-SP.BOX
Y13 411 021 3404 SCR S-TPG BIN 3X10,
HOLDER P.T-P.REAR
Y14 411 021 7204 SCR S-TPG BIN 4X10,
PANEL REAR-HOLDER TRANS
Y15 411 021 3404 SCR S-TPG BIN 3X10,HOLDER PWB
Y16 411 021 3404 SCR S-TPG BIN 3X10,
PANEL REAR-AC CODE FIXER
Y17 411 021 3404 SCR S-TPG BIN 3X10,HOLDER PWB
Y18 411 021 3404 SCR S-TPG BIN 3X10,
PANEL REAR-SHIELD REAR
Y19 411 098 4205 SCR S-TPG BIN 3X8,ANNTENA
Y20 412 070 7801 SPECIAL SCREW,FAN
SUBWOOFER SPEAKER ELECTRICAL-PARTS
REF.NO. PART NO. DESCRIPTION
8 645 051 0656 CORE,FERRITE,FOR TRANSMITTER
or 645 042 8999 CORE,FERRITE,FOR TRANSMITTER
51
!
!!
645 069 4349 TRANS,POWER
52
!
!!
423 027 5306 FUSE 125V 4A
53
!
!!
645 037 7747 CORD,POWER-1.845MK
or
!
!!
645 032 7537 CORD,POWER-1.86MK
54 614 332 2405 ASSY,WIRE,MAIN-INTERFACE
55 614 332 9220 ASSY,WIRE,TX-INTERFACE
56 645 071 5518 ANTENNA,ROD
57
!
!!
645 075 2018 MOTOR,FAN DC 1.2W
72
!
!!
614 332 9268 PWB,HOLD
76 645 071 4542 UNIT,WIRELESS TRANSMITTER
645 051 0656 CORE,FERRITE WIRE,
MAIN-INTERFACE
645 042 8999 CORE,FERRITE WIRE,
MAIN-INTERFACE
645 051 0656 CORE,FERRITE,FOR SPEAKER-WIRE
or 645 042 8999 CORE,FERRITE,FOR SPEAKER-WIRE
SUBWOOFER SPEAKER POWER AMP P.W.BOARD
ASSY
REF.NO. PART NO. DESCRIPTION
71 614 332 2368 ASSY,PWB,POWER AMP(Only initial)
C4707 403 386 2307 ELECT 1000U M 50V
C4710 403 386 2307 ELECT 1000U M 50V
C4723 403 185 0207 MT-POLYEST 0.56U J 50V
C4724 403 185 0306 MT-POLYEST 0.68U J 50V
C4725 403 185 0306 MT-POLYEST 0.68U J 50V
C4726 403 185 0207 MT-POLYEST 0.56U J 50V
C4727 403 185 0306 MT-POLYEST 0.68U J 50V
C4728 403 185 0306 MT-POLYEST 0.68U J 50V
C4804 403 185 0306 MT-POLYEST 0.68U J 50V
C4805 403 185 0306 MT-POLYEST 0.68U J 50V
C4806 403 185 0207 MT-POLYEST 0.56U J 50V
C4807 403 185 0306 MT-POLYEST 0.68U J 50V
C4808 403 185 0306 MT-POLYEST 0.68U J 50V
C4809 403 184 9805 MT-POLYEST 0.22U J 50V
C4812 403 386 2307 ELECT 1000U M 50V
C4815 403 386 2307 ELECT 1000U M 50V
CN492 645 008 4522 PLUG,HOUSING 2P
CN493 645 072 1953 TERMINAL,SPEAKER 3P
CN494 645 040 1206 SOCKET,13P
CN495 645 006 1912 PLUG,6P
CN496 614 310 2298 PLUG,2P
or 645 004 2683 PLUG,2P
CN497 645 072 9898 JACK,PHONE D3.6
D4700 407 241 7704 DIODE US1D-LF
D4701 407 241 7704 DIODE US1D-LF
D4702 407 241 7704 DIODE US1D-LF
D4703 407 241 7704 DIODE US1D-LF
D4704 407 241 7704 DIODE US1D-LF
D4705 407 241 7704 DIODE US1D-LF