Sanyo EM-P410WS - Page 8

WhenWhen
WhenWhen
When
When notWhen not
When notWhen not
When not
ResistanceResistance
ResistanceResistance
Resistance
touchedtouched
touchedtouched
touched
touchedtouched
touchedtouched
touched
valuevalue
valuevalue
value
Less thanLess than
Less thanLess than
Less than
More thanMore than
More thanMore than
More than
1K Ohms1K Ohms
1K Ohms1K Ohms
1K Ohms
1 MEG Ohm1 MEG Ohm
1 MEG Ohm1 MEG Ohm
1 MEG Ohm
COMPONENT COMPONENT
COMPONENT COMPONENT
COMPONENT
CHECKOUT PROCEDURE CHECKOUT PROCEDURE
CHECKOUT PROCEDURE CHECKOUT PROCEDURE
CHECKOUT PROCEDURE
RESUL RESUL
RESUL RESUL
RESUL
TT
TT
T
MeasurMeasur
MeasurMeasur
Measur
e the re the r
e the re the r
e the r
esistance between teresistance between ter
esistance between teresistance between ter
esistance between ter
minals ofminals of
minals ofminals of
minals of
FPC connector after rFPC connector after r
FPC connector after rFPC connector after r
FPC connector after r
emoving it fremoving it fr
emoving it fremoving it fr
emoving it fr
om S101.om S101.
om S101.om S101.
om S101.
(Figure 9).(Figure 9).
(Figure 9).(Figure 9).
(Figure 9).
TOUCH KEYTOUCH KEY
TOUCH KEYTOUCH KEY
TOUCH KEY
NOTE NOTE
NOTE NOTE
NOTE
BOARDBOARD
BOARDBOARD
BOARD
- When r- When r
- When r- When r
- When r
econnecting the FPC connectoreconnecting the FPC connector
econnecting the FPC connectoreconnecting the FPC connector
econnecting the FPC connector
, make, make
, make, make
, make
When checking “STWhen checking “ST
When checking “STWhen checking “ST
When checking “ST
ARAR
ARAR
AR
T” key, connectT” key, connect
T” key, connectT” key, connect
T” key, connect
sure the holes on the connector are properlysure the holes on the connector are properly
sure the holes on the connector are properlysure the holes on the connector are properly
sure the holes on the connector are properly
ohm-meter as illustration below.ohm-meter as illustration below.
ohm-meter as illustration below.ohm-meter as illustration below.
ohm-meter as illustration below.
inserted in hooks of the plastic fastener in S101.inserted in hooks of the plastic fastener in S101.
inserted in hooks of the plastic fastener in S101.inserted in hooks of the plastic fastener in S101.
inserted in hooks of the plastic fastener in S101.
MAMA
MAMA
MA
TRIX CIRCUIT FORTRIX CIRCUIT FOR
TRIX CIRCUIT FORTRIX CIRCUIT FOR
TRIX CIRCUIT FOR
TOUCH KEY BOARD TOUCH KEY BOARD
TOUCH KEY BOARD TOUCH KEY BOARD
TOUCH KEY BOARD
FPC CONNECTORFPC CONNECTOR
FPC CONNECTORFPC CONNECTOR
FPC CONNECTOR
Figure 9Figure 9
Figure 9Figure 9
Figure 9
Ohm-meterOhm-meter
Ohm-meterOhm-meter
Ohm-meter
- 6 -
TERMINALS OF FPC CONNECTORTERMINALS OF FPC CONNECTOR
TERMINALS OF FPC CONNECTORTERMINALS OF FPC CONNECTOR
TERMINALS OF FPC CONNECTOR
CHECKOUT PROCEDURE FOR SWITCHESCHECKOUT PROCEDURE FOR SWITCHES
CHECKOUT PROCEDURE FOR SWITCHESCHECKOUT PROCEDURE FOR SWITCHES
CHECKOUT PROCEDURE FOR SWITCHES
Disconnect the lead wirDisconnect the lead wir
Disconnect the lead wirDisconnect the lead wir
Disconnect the lead wir
es fres fr
es fres fr
es fr
om the switches and check for the continuity of the switches, connecting an ohm-meterom the switches and check for the continuity of the switches, connecting an ohm-meter
om the switches and check for the continuity of the switches, connecting an ohm-meterom the switches and check for the continuity of the switches, connecting an ohm-meter
om the switches and check for the continuity of the switches, connecting an ohm-meter
to its terto its ter
to its terto its ter
to its ter
minals.minals.
minals.minals.
minals.
SWITCHES SWITCHES
SWITCHES SWITCHES
SWITCHES
CHECKOUT PROCEDURES CHECKOUT PROCEDURES
CHECKOUT PROCEDURES CHECKOUT PROCEDURES
CHECKOUT PROCEDURES
DOOR OPEN DOOR OPEN
DOOR OPEN DOOR OPEN
DOOR OPEN
DOOR CLOSED DOOR CLOSED
DOOR CLOSED DOOR CLOSED
DOOR CLOSED
(See Figure 1 on page 1) (See Figure 1 on page 1)
(See Figure 1 on page 1) (See Figure 1 on page 1)
(See Figure 1 on page 1)
Primary Interlock Primary Interlock
Primary Interlock Primary Interlock
Primary Interlock
TT
TT
T
erer
erer
er
minals “COM” and “NO”minals “COM” and “NO”
minals “COM” and “NO”minals “COM” and “NO”
minals “COM” and “NO”
Door Sensing Door Sensing
Door Sensing Door Sensing
Door Sensing
Interlock Monitor Interlock Monitor
Interlock Monitor Interlock Monitor
Interlock Monitor
TT
TT
T
erer
erer
er
minals “COM” and “NC”minals “COM” and “NC”
minals “COM” and “NC”minals “COM” and “NC”
minals “COM” and “NC”
CAUTION :CAUTION :
CAUTION :CAUTION :
CAUTION :
After checking the switches, make surAfter checking the switches, make sur
After checking the switches, make surAfter checking the switches, make sur
After checking the switches, make sur
e that the interlock monitor switch is pre that the interlock monitor switch is pr
e that the interlock monitor switch is pre that the interlock monitor switch is pr
e that the interlock monitor switch is pr
operly connected accoroperly connected accor
operly connected accoroperly connected accor
operly connected accor
dingding
dingding
ding
to the CIRCUIT DIAGRAM on page 3.to the CIRCUIT DIAGRAM on page 3.
to the CIRCUIT DIAGRAM on page 3.to the CIRCUIT DIAGRAM on page 3.
to the CIRCUIT DIAGRAM on page 3.
065
1
2
3
4
7
8
9
STOP /
CLEAR
FRESH
VEGETABLE
POWER
LEVEL
SOUP /
BEVERAGE
MORE +
LESS -
TOTAL
DEFROST
QUICK
ON
CLOCK POPCORN
PIZZA START
FROZEN
VEGETABLE
CUSTOM
PROGRAMS
ADD
30 SEC
KITCHEN
TIMER
FROZEN
ENTREE
QUICK
DEFROST
POTATO