8. Storing the generating set
In case of prolonged non-usage of the generating set, carry out storage operations in accordance with the guidelines given below.
n Drain all the fuel from the fuel tank into a suitable container.
o Run the engine till it stops due to lack of fuel.
p Renew the engine oil.
q Remove the spark plug (fig. E – no. 2) and pour around 15ml of engine oil into the cylinder through the spark plug opening.
r Refit the spark plug.
s Pull the recoil starter handle 3 to 4 times (fig. A – no. 7) to completely drain-out the carburetor and distribute the oil inside the
cylinder.
t Clean the exterior of the generating set and cover it with the protection cover in order to protect it from dust.
u Store the generating set in a clean and dry spot.
9. Troubleshooting
Problems Probable cause Possible solutions
The engine does
not start
Load connected to the generating set while starting. Disconnect the load
The oil level is too low. Check the oil level and top up if necessary.
Insufficient fuel level Fill-up fuel (see § Filling with fuel)
Fuel feed system blocked or elusive Check, repair or replace.*
Air filter blocked Clean the air filter
The engine
stops
Ventilation openings blocked Clean the suction and discharge guards
The oil level is too low. Check the oil level and top up if necessary.
Overload indicator (fig. A – no. 11) turned on: overload.
Eliminate the overload and wait for 30sec before
restarting.
No electric
current
Defective device power supply cord. Change the cord.
Defective electrical socket. Check, repair or replace.*
Defective alternator. Check, repair or replace.*
* Operation(s) to be entrusted to one of our agents.
10. Specifications
Model
NEO 3000
Type of Engine OLYMP ES 128-1
Maximum output / Rated output 2600 W / 2100 W
Direct Current 12V-5A
Alternating Current 230V-9.2A
Socket type 2 x 2P+T - 10/16A - 230V
Circuit-breaker ●
Oil cut-out ●
Battery X
Acoustic pressure level at 1 m in dB(A) 73 dB(A)
Weight in kg (without fuel) 24
Dimensions L x w x h in cm 59 x 30 x 55
Recommended oil SAE 15W40
Oil sump capacity in litres 0.55
Recommended fuel Unleaded petrol
Fuel tank capacity in litres 4.3
Spark plug CHAMPION : RN9YC / NGK :BPR6ES
● : standard o : optional X : not possible
To Next Page
Loading...
Need help?
General
