6.2.3 ENGINE MAINTENANCE
DANGER When working on the generator, always disconnect spark plug wire from spark plug and keep wire away from
spark plug.
6.2.4 IL Changing the oil
Change the oil after the first five hours of operation, then every 20 hours thereafter. If running this unit under dirty or dusty
conditions, or in extremely hot weather, change the oil more often.
CAUTION Hot oil may cause burns.
Allow engine to cool before draining oil. Avoid prolonged or
repeated skin exposure to used oil. Thoroughly wash
exposed areas with soap.
Follow below instructions to change the oil while the engine
is cooling down:
Clean area around oil drain plug.
Remove oil drain plug from engine to drain oil completely
into a suitable container.
When oil has completely drained, install oil drain plug and
fasten securely.
Fill engine with recommended oil. (See “Before Starting the
Generator” for oil recommendations).
Wipe up any spilled oil.
Dispose used oil at a proper collection center.
6.2.5 REPLACING THE SPARK PLUG
Use spark plug F6TC, BPR4ES or Champioin RN14YC.Replace
the plug once each year. This will help the engine start easier
and run better.
Stop the engine and pull off the spark plug wire.
Clean the area around the spark plug and remove it from the
cylinder head.
Set the spark plug’s gap to 0.70-0.80 mm (0.028-0.031 in.).
Install the correctly gapped spark plug into the cylinder head
and torque to 15 ft/lbs.
6.2.6 SPARK ARRESTOR
Shut off generator and allow the engine and muffler to cool
down completely before servicing spark arrestor (located on
the back of the muffler).
Remove the clamp and spark arrestor screen.
Clean the spark arrestor screen with a small wire brush.
Replace the spark arrestor if it is damaged.
Install the Spark arrestor reversely.
6.3 SERVICE AIR FILTER
The engine will not run properly and may be damaged if
using a dirty air filter. Replace the air filter once a year. Clean
or replace more often if operating under dusty conditions.
Remove air filter cover.
Wash in soapy water. Squeeze filter dry in clean cloth (DO
NOT TWIST).
Clean air filter cover before re-installing it.
May drop a bit of engine oil to avoid ice blocked during
winter season.
Italia Star Com Due S.R.L.
www.italiastar.ro
info@italiastar.ro
004/021.433.03.27
88
To Next Page
Loading...