LUBRICATION
________
_
AOOO
000
007
Frequency
Routine maintenance
is
necessary for
all
mechanized products and snowmobiles
are
no exception. A weekly vehicle in-
spection greatly contributes to the life
span
of
the snowmobile.
It
is
recommendecj that the steering
system and suspension
be
lubricated
monthly or every
40
hours of operation.
If the vehicle
is
operated
in
wet snow
or
in
severe conditions these items
should
be
lubricated more frequently.
Penetrating lubricant
is
recommended
on moving parts.
Use
either:
-chain
lube from BARDAHL
(BCS
362, dry)
-
WD-40
Other grease fittings require low temper-
ature grease
(P/N 413 7061 00) using
standard grease gun.
The following symbols will
be
used to
show what type
of
lubricant should
be
used at required locations.
Chain lube
or
WD-40
Low
temperature
t-f!iiiiiiiil--
grease
AOOO
006
001
0
NOTE : When lubricating through
grease
fittings, slowly pump
grease
gun until grease appears at joints. Al-
ways use low temperature grease
(PIN
413 7061 00).
•
WARNING: Only perform such
procedures
as
detailed
in
this
manual. It
is
recommended that deal-
er assistance
be
periodically obtained
on
other components/systems not
covered
in
this manual. Unless other-
wise specified, engine should
be
turn-
ed
OFF for
all
lubrication and main-
tenance procedures. Do not lubricate
throttle
and
I
or
brake cables
and
hous-
ings.
25
To Next Page
Loading...
Need help?
General
