CHARGING METHORD
Pls charge 10-12 hours under 0.2ampere AC. Then the charging voltage is 12.5-12.6 volt, and the
performance of the battery could act 90%-100% which allow the battery could be used for quite a long
time.
If the battery is not used for a long time, pls take it away from the motorcycle to avoid discharging or
leaking automatically. Pls take apart the connector if the battery is left on the motorcycle.
AIR CLEANER
If the air cleaner filter is clogged with the dust, the intake resistance will be increased, resulting in the
reduction of output power and more consumption of the fuel. The checks and cleaning should be conducted
to the filter assembly for every 3,000km.
CAUTION
The battery cover cannot be dismounted and more once assembled, because the battery is
hermetic.
NOTE
Under dusty conditions, the air cleaner filter assembly must be cleaned or replaced more
frequently.
30
CLEANING THE FILTER ASSEMBLY
Clean the filter assembly as the following:
(1)Fill a washing pan of a proper size with non-flammable cleaning solvent(A),
immerse the filter assembly in the solvent and wash it clean.
(2)Squeeze the solvent off the washed filter assembly by pressing it between
the palms of both hands. Do not twist and wring it or it will develop fissures.
(3)Immerse the filter assembly in a pool of motor oil (B) and squeeze the oil
off it to make it slightly wet with oil.
CAUTION
Before and during the cleaning operation, carefully examine the filter assembly for any
crackles. A new one should be replaced if a crackle is observed.
(4)Reinstall the cleaned filter assembly. Be absolutely sure that the filter assembly is securely in position
and is sealed properly.
CAUTION
Never start the engine without the filter assembly in position. It will quicken engine wear and
shorten the engine service life.
SPARK PLUG
After the first 1,000km and afterwards every 3,000km riding, remove
the carbon deposits from the spark plug with a small metal wire brush
or a spark plug cleaner. Re-adjust the electrode gap of spark plug with
a gap thickness gauge to make it between 0.6 to 0.7mm
The spark plug should be replaced after every 6,000km riding.
31
To Next Page
Loading...