SPARK PLUG
Select the THUNDER brand 1E6 or TORCH brand
T1136 spark plug.
After the first 1000km and afterwards every
3000km riding, remove the carbon deposits from the
spark plug with a small metal wire brush or a spark
plug cleaner. Readjust the electrode gap of spark plug
with a gap thickness gauge to make it between 0.6 to
0.7 mm. The spark plug should be replaced after every
6000km riding.
NOTE
Never operate the engine without the element
in position.
Operating the engine without the air cleaner
element will increase engine wear. The life of
the engine depends largely on this single
component.
CAUTION:
The standard spark plug for this motorcycle
has been carefully selected to meet the most
operation ranges. If the spark plug color differs
from a standard one, you should better consult
your SKYTEAM dealer before selecting an
alternating plug on a beat range. The selection
of an improper spark plug can lead to severe
engine damage and driving difficult.
CAUTION:
Do not over torque the spark plug otherwise
threads of the cylinder head will be damaged.Do
not allow contaminations to enter the engine
through the spark plug hole when the plug is
removed.
TRANSMISSION OIL (SHIFTING
GEAR OIL)
After a long time driving, the shifting gear oil in
the transmission may degrade, which could reduce the
lubricating performance of the oil. Therefore, after first
31
1000km driving and after-wards every 6000km,
change the oil according to the following instructions.
Changing the luboil in the engine should be carried
out when the engine is warm.
Remove the engine oil filler cap/dipstick then
the drain cock to drain the oil fully. The used oil
drainage should be carried out. Then refit the drain
cock, pour the new luboil by the oil filler hole. Check
the luboil level with a dipstick: insert a dipstick into
the gear box, the oil level should be between the
marks111 and ( Do not screw in the dipstick into the
hole).
CARBURETOR
Undisturbed carburetion is the basis of the
performance you ought to expect from your engine.
The carburetor is factory set for the best carburetion.
Do not attempt to alter its setting. There are two
adjustments that you should take care are: Adjust
engine idle speed and throttle cable play periodically.
32
To Next Page
Loading...