Sullair VCC-200 - Page 117

Section 11
ILLUSTRATIONS AND PARTS LIST
109
11.16 PNEUMATIC CONTROLS- V-200
key part
number description number quantity
1 tee, male pipe brass 1/4 869825-025 5
2 nipple, pipe-hx pltd 1/2 x 1/2 868508-050 1
3 bushing, red pltd 3/8 x 1/4 867101-010 1
4 elbow, pipe-90m 1/4 x 1/4 860504-025 1
5 elbow, 37fl 90m 1/2 x 1/2 860208-050 1
6 elbow, 37fl 90m 1/2 x 1/4 860208-025 1
7 nipple, chase cond 1/2 847815-050 2
8 bulkhead, pipe 1/4” npt 841500-004 2
9 plug, pipe 1/8” 3000# stl 807800-005 1
10 valve, shuttle 1/4” npt (dbl chk) 408893 2
11 connector, straight 1/4t plsx 1/4npt f 250041-084 4
12 elbow, 90 1/4t pls x 1/4 npt m 250018-430 7
13 elbow, 90 1/4”tube x 1/8”npt 250018-429 1
14 connector,1/4”tube x 1/4”npt 250018-428 5
15 valve, pressure regulator (I) 250017-280 1
16 hose, med press 0.50 x 032” 249608-008 1
17 nipple, brass hex 1/4”-npt 249537 4
18 strainer, v-type 300psi x 1/4 (II) 241771 2
19 support, bracket strainer 02250134-380 1
20 orifice, cap .031” x 1/4” npt 02250132-934 2
21 valve, solenoid 3wno 1/4 235# n4(III) 02250125-657 2
22 valve, 1/2 bldwn 1.8:1 250 psig (IV) 02250100-042 1
23 locknut, n4 conduit sealing 02250071-362 2
24 tube, nyl .25od x 040w blk 02250054-861 1 ft.
25 regulator, reducing 1/4 npt (V) 02250046-568 1
(I) For maintenance on pressure regulator valve no. 250017-280, order repair kit no. 250019-453.
(II) For maintenance on strainer no. 241771, order repair kit no. 241772.
(III) For maintenance on solenoid valve no. 02250125-657, order repair kit no. 02250125-829, and replace-
ment coil no. 02250125-861.
(IV) For maintenance on blowdown valve no. 02250100-042, order repair kit no. 02250045-132.
(V) For maintenance on reducing regulator no. 02250046-568, order repair kit no. 02250055-911.
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE THE SERIAL NUMBER OF COMPRESSOR