Suzuki GP125 - Page 29

2-14
The extension line of the index mark is
within the range
To
check
wear
of
the
brake
lining,
perform
the
following steps.
*
First
check
if
the
brake
system
is
properly
adjusted.
*
While
operating
the
brake,
check
to
see
that
the
extension
line
of
the
index
mark
is
within
the
range
on
the
brake
panel
*
If
the
index
mark
is
beyond
the
range
as
shown
in
the
Fig.,
the
brake
shoe
assembly
should
be
replaced
with
a
new
one.
The
extension
line
of
the
index
mark
is
beyond
the
range.
DRIVE CHAIN
Check and adjust at initial 1 000 km
(600 mi) and every 3 000 km (2 000 mi)
Lubricate every 3 000 km (2 000 mi)
Wash every 6 000 km (4 000 mi)
Visually inspect the drive chain for the below.
listed possible malconditions.
* Loose pins
* Damaged rollers
Rusted links
Twisted or seized links
* Excessive wear
If any defects are found, the drive chain must be
replaced
Checking
*
Loosen
axle
nut
1
after
pulling
out
cotter
pin
2
*
Tense
the
drive
chain
fully
by
tightening
the
adjusters
3
* Remove the chain case. Count out 21 pins (20
pitch) on the chain and measure the distance
between the two. If the distance exceeds
following limit, the chain must be replaced.