Suzuki GSXR-1100 1990 - Page 24

-
PERIOOI C MAINTENANCE AND TUNE , UP PROCEDURES 2- 10
WARNIN G:
Tho chitch $ys tem of 1his motorcyclu is filled with a
glycol • based brok o f lu l<I . Do not u$e or mix different typos
of flu id .such as s ili co ne-based and p et roloum•basod . Do not
use any brok e fluid tak en from old, used or unsualod
co nt ah , ers. N ever re - use brak e fluid loh ov or fro m the las1
servicing or sto red for lo ng pe riods .
BLE EOING AIR FROM THE CLUTCH FLUIO CIRCUIT
The clutch fluid circuit may be purged ol < ill ,n the fo ll owing
ITI{H)OC( ,
• Remove the l ow&r falrinn
• Kcop 1h e motorcyc le uprig ht a ud l) l:e1c e the h am .ll abors
~traig ht.
• FI ii up the mast er cy lind er rosorvoir to th~ uppe r end of th e
in sp ec tion wiodow , Repl ace th e resa rvo,r C3 P 10 , ,,ev ent
enuy of rtirt .
• Att<.1ch a JJip c to 1h e hl P.P.dP.r valve um .I in s cn 1h e fre e end of
the f)i pe into a rece pt.:ic lc .
• Squeeze ;.111(1 rei e::.s e th e dut c h t evar ~cv<:r f! I ti1n ~s in rap id
succ ession. a nd squee .w Uw lev er fully without ru h. :osino it
Loosen the IJ lcc:d er valve by tu rni ng il u 1.1oarl er of ;i. turn so
l h -al th e f lui ri tun s int o lln 1 rccel)t;;il':le; th is wi ll ramvvo t he
tension 01 th e c lu tc h lev M ca usin g it lO lOuch the han d lebar
nr ip . Th en , clo se th e w iv e, punm 3n<l snee ze th e lover, t1 nd
op ~n th e valve . R~1> e,:i.t this process until the fluid fl owing into
th e receptacl e 1 10 1 011!.J O• co nrn in s ;i ir bub b h lS .
NOTE:
Repl &m 's l, (hf> c lut c /i /lu,t.J ; ,. the re.wu 1- · oir /JI:; 110Ct)$!'U1ry while
hl t)tU ting th e cl vu : I, .< W.-.tP.m. J'lt1ilktJ $ <n 'e l h, 'lt the re ,~· a /n, {W ,,;
scmw ft,u (I n' s;b/e m thv l'(:$f)fllOh '.
• C lo su th u Olood e, v~lve, ;an d d1sconnuct the f) il) e. Fill th e
res~ rv o ir to th e upper t:md of lh <:l I nspe c tion window ,
Ble e dur valvo
ti ghtening torque: 6 - 9 N,m
,- (0.6 - 0 . 9kg-m , 4 .5 - 6.5 lb • f1 )
CAUTION:
Hundlo l),ake fluid with co r e: th o r h,id reacts c hemi cu lly
with pa int , pl atHics, ,u hbe, materi a ls , e tc ,