Temco TFC39-3 - User Manual

READ AND SAVE THESE INSTRUCTIONS
TEMCO FIREPLACE PRODUCTS, Inc.
Installation Instructions for Low Profile, Front-Opening,
Wood-Burning Fireplaces
Models TLC42-4, TLC42-4I,TLC42-4MB, TFC42-4, TLC39-3, TLC39-3I, TFC39-3, TLC36-3,
TLC36-3I, TLC36-3MB, TFC36-3, A42L-4, A42F-4, A39L-3, A39F-3, A36L-3 and A36F-3
36" Louvered Heat Circulating Fireplace
42" Flush Face Heat Circulating Fireplace
FOR YOUR SAFETY
− Do not store or use gasoline or other flammable vapors and liquids in the vicinity
of this or any other appliance.
− Installation and service must be performed by a qualified installer. Do not attempt
to install this fireplace yourself!
If the information in this manual is not followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of life.
WARNING
P.O. BOX 1349 Manchester, TN 37349
P.O. Box 1148 Perris, CA 92572
A subsidiary of Temtex Industries, Inc.
PRINTED IN USA 02/97 7N70359C

Summary

Introduction and Basic Rules

TEMCO Chimney System Overview

Overview of the TEMCO double-wall 8" diameter air-cooled chimney system.

Basic Rules and Safety Guidelines

Key safety and installation guidelines for TEMCO fireplaces.

Planning Ahead for Fireplace Installation

Fireplace Location and Framing

Guidance on selecting the optimal placement and preparing framing dimensions for the fireplace.

Air Kits, Gas Logs, and Draft Management

Information on optional air kits, gas logs, and managing fireplace drafts for efficiency.

Chimney Clearances and Outlet Location

Considerations for chimney exit location and required clearances to combustibles.

Hearth Extension R-Value Requirements

Explains how to calculate thermal resistance (R-factor) for hearth extension materials.

Fireplace Installation Procedures

Firebox Framing, Mounting, and Safety Strip

Instructions for framing the opening, installing the hearth safety strip, and securing the firebox.

Chimney Framing, Firestops, and Assembly

Procedures for preparing openings, using firestops, and connecting chimney sections.

Offset Chimney and Termination Height

Rules for offset installations and determining correct chimney height above the roof.

Chimney Offset Calculations

Table showing rise and offset dimensions for chimney configurations with elbows.

Chase Installations and Connections

Flashing, Storm Collar, and Termination

Steps for installing roof flashing, storm collar, and the termination cap for a chase.

Gas Line and Cold Climate Installation

Instructions for gas line installation and advice on sealing/insulating for cold climates.

Mobile Home Installation

Firestop Thimble for Mobile Homes

Specifics on installing a firestop thimble for mobile home chimney penetrations.

Finishing and Styling Your Fireplace

Decorative Wall Treatments

Options for decorative finishing materials around the fireplace opening.

Mantel and Hearth Installation

Guidelines for mantel projection and installing raised or flat hearths.

Using Your Fireplace Safely and Effectively

Replacement Parts

Temco TFC39-3 Specifications

General

Fuel Type	Electric
Venting	Vent-Free
Model Number	TFC39-3
Voltage	120V
Remote Control	Yes
Overheat Protection	Yes
Cool Touch Exterior	Yes
Tip-Over Safety Switch	Yes
Finish	Black
Amperage	12.5 amps
Thermostat	Yes