Temco TLC36-3 - User Manual

READ AND SAVE THESE INSTRUCTIONS
TEMCO FIREPLACE PRODUCTS, Inc.
Installation Instructions for Low Profile, Front-Opening,
Wood-Burning Fireplaces
Models TLC42-4, TLC42-4I,TLC42-4MB, TFC42-4, TLC39-3, TLC39-3I, TFC39-3, TLC36-3,
TLC36-3I, TLC36-3MB, TFC36-3, A42L-4, A42F-4, A39L-3, A39F-3, A36L-3 and A36F-3
36" Louvered Heat Circulating Fireplace
42" Flush Face Heat Circulating Fireplace
FOR YOUR SAFETY
− Do not store or use gasoline or other flammable vapors and liquids in the vicinity
of this or any other appliance.
− Installation and service must be performed by a qualified installer. Do not attempt
to install this fireplace yourself!
If the information in this manual is not followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of life.
WARNING
P.O. BOX 1349 Manchester, TN 37349
P.O. Box 1148 Perris, CA 92572
A subsidiary of Temtex Industries, Inc.
PRINTED IN USA 02/97 7N70359C

Summary

Introduction

TEMCO Chimney System

Details on the TEMCO double-wall 8" diameter air-cooled chimney system components.

Planning Ahead

Choosing Fireplace Location

Guidance on selecting an optimal location, considering traffic, doors, windows, and wall types.

Before You Begin: Basic Rules

Fireplace Installation

Framing the Firebox Opening

Instructions for constructing the fireplace opening, ensuring the header is correct and level.

Hearth Safety Strip Installation

How to install a hearth safety strip under the fireplace on combustible floors.

Installing the Firebox

Step-by-step guide to placing and positioning the firebox into the framed opening.

Installing Firestop Spacer

Installing the Chimney

Detailed steps for assembling the double-wall chimney pipe sections correctly.

Offset Installations

Rules for Offset Installations

Guidelines for using elbows to create inclined chimney runs, including height and support requirements.

Chimney Termination Height

10 Foot Rule of Thumb

Standard guidelines for determining required chimney height relative to roof peaks and openings.

Installing Flashing

Installing Storm Collar

How to attach and secure the storm collar over the chimney pipe and flashing for weather protection.

Chase Installations

Chase Construction Basics

Information on building chases for fireplaces and chimneys, including clearances and insulation.

Installing a Gas Line

Recommended Cold Climate Installations

Insulating the Fireplace Enclosure

Tips for insulating fireplace enclosures to prevent cold air infiltration and improve efficiency.

Sealing Seams

Methods for sealing seams between the fireplace and finishing materials to prevent air leaks.

Mobile Home Installation

Finishing Your Fireplace

Wall Treatments

Options for decorative facing materials around the fireplace, noting clearance and material restrictions.

Brick or Stone Facing

Guidelines for applying brick or stone facing, including lintel requirements and enclosure needs.

Mantel Projection

Raised Hearth Installations

Detailed instructions for constructing raised hearths for flush and louvered fireplace models.

Using Your Fireplace

Replacement Parts

Temco TLC36-3 Specifications

General

Model	TLC36-3
Category	Indoor Fireplace
Venting	Direct Vent
Remote Control	Yes
Thermostat	Yes
BTU	36, 000 BTU
Fuel Type	Natural Gas or Propane
Voltage	120V