Tiger Cub User Manual

Solid Fuel Stoves Manual v177. Issued -
04/10/2019 (464)
LOW-EMISSIONS SOLID
FUEL HEATING STOVE
Eco 2022 version
INSTALLATION AND OPERATING INSTRUCTIONS
LEAVE THIS DOCUMENT WITH THE HOUSEHOLDER!
All Tiger Stoves exceed the safety and performance requirements of European Standards
Intermittent burning solid fuel roomheaters for installation with a single dedicated chimney.
Independently tested in 2019 by SGS Nederland BV, Arnhem Environmental
Laboratory, CEN Approved Laboratory No 0608
Fuel Wood Logs (Beech)
Test Standard
EN 13240 (Safety & Performance)
EN16510-1 (Emissions)
Test Cycle 1x 0.75kg log every 0.75hrs
Settings Air slide closed
Flue Draught Pa (ins WG) 11
Efficiency % 76%
Recommended Output Rating kW 4.0 kW
Mean Flue Gas Temp Rise ºC 264
Minimum air entry requirement 2200 mm²
Minimum Clearance to combustibles (allow
min 50mm clearance to non-combustibles)
500mm (150mm at rear with heat shield fitted)
- but see further instructions inside
Emissions as if
02=13%
NOx mg/m³ 101
CO % 0.05
CxHy mg(C)/m³ 29
Gas flow g/sec 4.6
Smoke Emission mg/m³ 23mg/m³ (≈ 0.29 g/hr)
I declare that this information is true, these products meet the requirements of Harmonised Standards and are fit for sale.
Signed on behalf of the manufacturer by Glyn Hughes, Design Engineer, at Winster, Derbyshire, England 4. Oct. 2019
Read these instructions! Use only recommended fuels!
This document, when completed by the installer, constitutes part of a 'Hearth Notice' for
purposes of Building Law. It must be left with the householder and placed where it can easily
be found.
INSTALLED AT LOCATION:
BY:
EMERGENCY CONTACT:
Flue Draught
measured on
commissioning:
Fuel used on
commissioning
I assert that this installation is safe, has been lit and demonstrated to the householder,
conforms with current building regulations and with these instructions
SIGNED: DATE:
TO FIND A QUALIFIED INSTALLER, FUEL SUPPLIER or CHIMNEY SWEEP, CONTACT:
UK: The Solid Fuel Association, 7 Swanwick Court, Alfreton, Derbyshire DE55 7AS Tel:0845-601-4406 www.solidfuel.co.uk
RoI: Irish Nationwide Fireplace Organisation, 162 Capel Street, Dublin 1 Tel:01-801-5959 www.fireplace.ie
Distributed only by: Percy Doughty & Co, Imperial Point, Stone Hill Rd, Farnworth, Bolton BL4 9TN
Tel: 01204-868-550
www.tiger-stoves.com
1
Pa
WG
(Shown with optional rear heat shield)

Tiger Cub Specifications

General

Fuel Type	Wood
Material	Steel
EPA Certified	Yes
Efficiency	75%
Burn Time	Up to 8 hours
Dimensions	24" H x 24" D
Heating Area	Up to 1, 200 sq ft

Summary

Installation and Operating Instructions

Technical Specifications

Key performance data including fuel type, test standards, efficiency, output rating, and emissions.

Installation

General Installation Requirements

Details on stove placement, chimney requirements, and essential safety clearances for installation.

Safe Clearances

Specifies minimum distances to combustible materials around the stove and flue pipe.

Air Supply

Information on the required permanent fresh air supply for proper stove operation.

Operating Your Stove

Lighting and Control

Guidance on starting the fire, controlling burn rate using the air slide, and managing fuel.

Fuel Recommendations

Details on suitable fuels, including wood, peat, coal, and briquettes, and those to avoid.

Maintenance and Cleaning

Instructions for cleaning the stove window and general upkeep for optimal performance.

Troubleshooting and Maintenance

Common Problems and Solutions

Addresses issues like smoke from chimney, poor heat output, and lack of controllability.

Chimney Maintenance

Guidance on chimney sweeping frequency and procedures to prevent fires.

Parts and Accessories

List of available replacement parts and optional accessories for the stove.