Greensmaster 3300 Page 3 -- 11 Gasoline Engine
Removal (Fig. 5)
1. Parkmachineonalevelsurface,disengageandlow-
er cutting units, move functional control lever to neutral
(N),engageparking brake,stopthe engineandremove
the key from the ignition switch. Wait for all machine
movement to stop.
DANGER
Gasolineisflammable.Usecautionwhenstoring
or handling it. Do not smoke while filling the fuel
tank. Do not fill fuel tank while engine is running
or in an enclosed area. Always fill fuel tank out-
side and wipe up any spilled fuel before starting
the engine. Store fuel in a clean, safety--ap-
proved container and keep the cap in place. Use
gasoline for the engine only; not for any other
purpose.
2. Remove leak detector tank (machines with Turf
Guardian
TM
Leak Detector System) or hydraulic reser-
voircover(machineswithoutTurfGuardian
TM
LeakDe-
tector System) to gain access to carbon cannister (see
Service and Repairs section of Chapter 5 -- H ydraulic
System).
3. Inspect carbon cannister and attached hoses for
damageorobviousleaks.Adamagedorleakingcannis-
ter should be replaced.
4. Remove components as needed using Figure 5 as
a guide.
A. If either purge hose assembly (item 27) or tee
hoseassembly(item28)istoberemoved,labelends
of hose for assembly purposes. Both of these as-
sembliesincludeacheckvalvesodirectionofinstal-
lation is important for correct operation of the
evaporative control system. The check valve is not
available as a separate part so hose assembly re-
placement isnecessary if the checkv alve or hose is
faulty. To ensure proper operation of check valves,
donotattempttoremovethemfromthehoseassem-
bly.
Installation (Fig. 5)
1. Install all removed components using Figure 5 as a
guide.
A. If either purge hose assembly (item 27) or tee
hose assembly (item 28) was removed, make sure
that installation is correct.
B. Make sure that fuel hoses are not kinked after
installation.Also,secureallhoseswithhoseclamps.
2. Install leak detector tank (machines with Turf Guar-
dian
TM
Leak Detector System) or hydraulic reservoir
cover (machines without Turf Guardian
TM
Leak Detec-
tor System) (see Service and Repairs section of Chap-
ter 5 -- Hydraulic System).
Figure 6
1. Carbon cannister
2. Screw (2 used)
3. Cannister bracket
4. Leak detector tank
FRONT
4
1
2
3
Gasoline
Engine
To Next Page
Loading...
