TUG Technologies 663 - Page 8

Introduction - 1 - viii CD397-Oper
Mobile Belt Loader Model 660
Operation Manual
Introduction
3.11.5.2 Deutz 2.9L..............................................................................Operation - 3 - 45
3.11.6 Emergency Stop Switch..................................................................Operation - 3 - 45
3.11.7 Park Brake ......................................................................................Operation - 3 - 45
3.11.8 Pilot-Operated Hydraulic Check Valves..........................................Operation - 3 - 45
3.11.9 Safety Props ...................................................................................Operation - 3 - 46
3.11.10 Side / Hand Rails ..........................................................................Operation - 3 - 46
3.11.11 Finger Guards ...............................................................................Operation - 3 - 46
3.11.12 Rubber Bumper Roll .....................................................................Operation - 3 - 46
3.11.13 Steel Hoop Guard (Optional) ........................................................Operation - 3 - 46
3.11.14 Grit Paper......................................................................................Operation - 3 - 46
Section 4: Shipping .................................................................................... Operation - 4 - 47
4.1 Shipping Preparation .................................................................................Operation - 4 - 47
4.1.1 Fuel Tank Preparation .....................................................................Operation - 4 - 47
4.1.2 Battery Preparation ..........................................................................Operation - 4 - 47
4.1.3 Pre-shipping Verification ..................................................................Operation - 4 - 47
4.2 Receiving ...................................................................................................Operation - 4 - 48
4.2.1 Preparing for Operation ....................................................................Operation - 4 - 48
4.2.1.1 Battery......................................................................................Operation - 4 - 48
4.2.1.2 Emergency Hydraulic Pump.....................................................Operation - 4 - 48
4.2.1.3 Radiator....................................................................................Operation - 4 - 48
4.2.1.4 Fuel Cell...................................................................................Operation - 4 - 48
Section 5: Storage ...................................................................................... Operation - 5 - 49
5.1 Short Term Storage ...................................................................................Operation - 5 - 49
5.1.1 Gasoline Engine................................................................................Operation - 5 - 49
5.1.1.1 Ford 2.5 L Engine.....................................................................Operation - 5 - 49
5.1.1.2 Transmission............................................................................Operation - 5 - 49
5.1.1.3 Drive Axle.................................................................................Operation - 5 - 49
5.1.1.4 Tires .........................................................................................Operation - 5 - 50
5.1.1.5 Lubrication................................................................................Operation - 5 - 50
5.1.1.6 Battery......................................................................................Operation - 5 - 50
5.1.1.7 Fluid Levels..............................................................................Operation - 5 - 50
5.1.2 Diesel Engine....................................................................................Operation - 5 - 50
5.1.2.1 Deutz 2.9L Engine....................................................................Operation - 5 - 50
5.1.2.2 Transmission............................................................................Operation - 5 - 50
5.1.2.3 Drive Axle.................................................................................Operation - 5 - 50
5.1.2.4 Tires .........................................................................................Operation - 5 - 51
5.1.2.5 Lubrication................................................................................Operation - 5 - 51
5.1.2.6 Battery......................................................................................Operation - 5 - 51
5.1.2.7 Fluid Levels..............................................................................Operation - 5 - 51
5.2 Returning the Vehicle to Operation After Short Term Storage...................Operation - 5 - 51
5.2.1 Tires ..................................................................................................Operation - 5 - 51
5.2.2 Battery...............................................................................................Operation - 5 - 51
5.2.3 Engine...............................................................................................Operation - 5 - 52
5.2.4 Transmission.....................................................................................Operation - 5 - 52
5.3 Long Term Storage....................................................................................Operation - 5 - 52
5.3.1 Gasoline Engine................................................................................Operation - 5 - 52
5.3.1.1 Ford 2.5L Engine......................................................................Operation - 5 - 52
5.3.1.2 Engine Exterior.........................................................................Operation - 5 - 53
5.3.2 Transmission.....................................................................................Operation - 5 - 53
5.3.2.1 Drive Axle.................................................................................Operation - 5 - 54