TYM T700 - Fuel Saving Tips and Fault Tracing; Fuel Saving Tips

SPECIFICATIONS
Model: T700
ENGINE
Four strokes, Direct injection, water-cooled
Diesel Engine.
CLUTCH
Type : Diaphragm
Outer dia. X Inner dia. : 275X180(10.83X7.09)
Model :CD3029TF270E
No. of cylinders :3
Displacement :2,911 Liters
Bore :106.5mm(4.19”)
Stroke :110mm(4.33”)
Compression Ratio :17.8:1
Rated power (PS) :72/2500 rpm
(Manufacturing rating)
Rated S
p
eed :2500 r
pm
TRANSMISSION
Type : synchro mesh
No. of gears :16 forward,
16 reverse speeds
with high and low
selection lever with
Differential Lock
STEERING : Hydraulic power
(
Power steerin
g)
p
p
High idle rpm :2,700-2,750 RPM
Low idle rpm : 775~875 RPM
Fuel injection pump :Stanadyne.
Cylinder sleeve :Wet-replaceable
Air Cleaner : Dry Filter element,
paper element filtering type.
Exhaust Muffler : Vertical External type
Firing order : 1-2-3
Accelerator : Hand & Foot Accelerator
(g)
POWER TAKE OFF
Rear mounted : 6 splines
Diameter : 1⅜ in.(35mm)
Standard PTO : ①554 ②1000(755)
BRAKES
Foot operated, independent with provision of
inter lock for simultaneous operation. A foot
brake is fitted for parking.
Disc Diameter :
Φ184mm(Φ724in)
Accelerator
:
Hand
&
Foot
Accelerator
ELECTRICAL STARTING AND LIGHTING
Battery Capacity : 12 Volt 110AH
Starter :Solenoid Engaged.
Key Start with interlock
, Neutral switch
Alternator :12V 50A(70A)
Instrumentation :Water Temperature Gauge,
TtHt
Disc
Diameter
:
Φ184mm(Φ7
.
24
in)
Number of lining :6 each side
Total brake thickness : 66.4㎜(2.614in.)
HYDRAULIC SYSTEM
Independent fully”Live”hydraulic pump
and separate reservoir.Position controls with
isolating & response control
Pi t d li d Lift
1316 K f
T
aco me
t
er,
H
our me
t
er,
Electrical fuel level gauge.
Lighting: Head lamps, side indicators,
Rear parking brake &
indicator light, Front
parking & indicator light,
On dash board indicators
for battery charging, turn
Pi
s
t
on an
d
cy
li
n
d
er
Lift
1316
K
g
f
(at lower link top end)
Pump output :Front:16.8 ㎤/rev
:Rear: 8.2 ㎤/rev
Delivery(91% efficiency) : liter(cu.in)mm at
2500rpm
3 point linkage : category 2
adjustable outside stabilizer
100
signal, PTO signal, Engine
oil pressure, Preheat signal.