TYM T700 - Fault Tracing

SYMPTOM CAUSE REMEDY
Turning the main switch
will not operate the starter
Clutch not pushed in
Battery flat
Push the clutch in
Charge or replace the battery
Dealer to repair or replace
FAULT TRACING
Switch faulty
Dealer
to
repair
or
replace
Contact dealer for repair or
replace
Starter operates but not
enough to turn the engine
Low battery
Bad earth
Thick oil
Charge the battery
Clean the earth lead and tighten
Drain and replace with correct oil
Engine
Starter operates OK but
does not start the engine
Air in fuel syste
m
Clogged fuel filter
No fuel being supplied
Glow plug disconnected or
not working
Bleed the syste
m
Clean or replace both filters
Fill tank or turn tap on
Contact dealer for repair.
Engine revolutions are
irregular
Air in the fuel system
Faulty injector
Bleed the system
Contact dealer for repair.
Fuel pipe lea
k
The engine stops at low
revolution
Poor fuel injection
Faulty injection pump
Wrong valve clearance
Wrong idle setting
Faulty injector
Contact dealer for repair
Contact dealer for repair
Contact dealer for repair
Contact dealer for repair
Contact dealer for repair
The engine stops suddenly
Lack of fuel
Fill the tank and bleed the fuel
The
engine
stops
suddenly
Lack
of
fuel
Faulty injectors
Seized engine due to lack
of oil, the wrong oil or lack
of coolant
Fill
the
tank
and
bleed
the
fuel
system
Contact dealer for repair
The engine overheats Lack of coolant
Broken or misadjusted fan
Refill with coolant
Adjust or replace
106
Broken
or
misadjusted
fan
belt
Clogged air filter element
Clogged radiator
Low oil
Adjust
or
replace
Clean or replace air filter
Clean the core
Replace the oil to correct grade