4242
6. Lubrication of mast6. Lubrication of mast
Lubrication here on schedule, refers to figure asLubrication here on schedule, refers to figure as
below:below:
MastMast
Paint lubrication grease on the slide support.Paint lubrication grease on the slide support.
Note:Note:
a. The periods of paint lubrication grease dependa. The periods of paint lubrication grease depend
on the truck‘s work condition. If work is heavy, pleaseon the truck‘s work condition. If work is heavy, please
paint much more grease on mast.paint much more grease on mast.
b. To assist with the truck‘s opb. To assist with the truck‘s operation, paint someeration, paint some
lubrication grease on the surface where the idler pulleylubrication grease on the surface where the idler pulley
and inside and outside masts touch.and inside and outside masts touch.
!! CCaauuttiioonn
When applying lubrication grease; stopWhen applying lubrication grease; stop
the truck on a smooth road, engine off andthe truck on a smooth road, engine off and
pull hand brake. Avoid injury to hand or body,pull hand brake. Avoid injury to hand or body,
and avoid falling off from high place. Keepand avoid falling off from high place. Keep
safe.safe.
7. Chain/Mast Lubrication7. Chain/Mast Lubrication
For the lubrication points of each of the followingFor the lubrication points of each of the following
parts, see the Lubrication System Diagram.parts, see the Lubrication System Diagram.
（（
11
））
Mast Bearing LubricateMast Bearing Lubricate
（（
22
））
Brake PedalBrake Pedal
（（
33
））
Inching PedalInching Pedal
（（
44
））
Steering Axle ShaftSteering Axle Shaft
（（
55
））
Steering Knuckle Main Bearing LubricateSteering Knuckle Main Bearing Lubricate
（（
66
））
Steering Rod Bar PinSteering Rod Bar Pin
（（
77
））
Steering Cylinder PinSteering Cylinder Pin
8. Bolt and 8. Bolt and Nut TighteningNut Tightening
Reference theReference the
《《
Maintain Cycle ChartMaintain Cycle Chart
》》
..
To Next Page
Loading...
