Velopex Intra-X - Page 15

6%,/0%8).42!8
5SER'UIDE
).34!,,!4)/.

,OWER4RANSPORT-ODULESCAREFULLY
INTOTHEIRRESPECTIVETANKS4OPUP
THECORRECTLIQUIDLEVELWILLSHOW
HALFWAYUPTHESIGHTGLASS
&ILLTHETANKSUPTOTHELOWEST
EDGEOFTHE3IGHT'LASS
&ILLINGWITH#HEMICALSCONT


7!2.).' 4HISLIQUIDLEVEL
SHOULDBEMAINTAINEDATALLTIMES
'REASE)MMERSION(EATERSFOR
$EVELOPERAND&IXERTANKSWITHTHE
LUBRICANTPROVIDED

4)0 3PREADATHINSMEAROFLUBRICANT
OVERTHETWOPROJECTINGMETALHEATING
ELEMENTS
7!2.).' $O./4OVER
GREASE
6%,/0%8).42!8
5SER'UIDE
).34!,,!4)/.

,OWER4RANSPORT-ODULESCAREFULLY
INTOTHEIRRESPECTIVETANKS4OPUP
THECORRECTLIQUIDLEVELWILLSHOW
HALFWAYUPTHESIGHTGLASS
&ILLTHETANKSUPTOTHELOWEST
EDGEOFTHE3IGHT'LASS
&ILLINGWITH#HEMICALSCONT


7!2.).' 4HISLIQUIDLEVEL
SHOULDBEMAINTAINEDATALLTIMES
'REASE)MMERSION(EATERSFOR
$EVELOPERAND&IXERTANKSWITHTHE
LUBRICANTPROVIDED

4)0 3PREADATHINSMEAROFLUBRICANT
OVERTHETWOPROJECTINGMETALHEATING
ELEMENTS
7!2.).' $O./4OVER
GREASE
Filling with Chemicals (Cont.)
INSTALLATION
VELOPEX INTRA-X 7
User Guide
11.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
Fill the tanks up to the lowest edge
of the Sight Glass.
Lower Transport Modules carefully
into their respective tanks. Top up
- the correct liquid level will show
half way up the sight glass.
WARNING: This liquid level should be
maintained at all times.
Grease immersion heaters for
developer and fixer tanks with the
lubricant provided.
TIP: Spread a thin smear of lubricant
over the two projecting metal heating
elements.
WARNING: Do NOT over grease.
12 .
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
13 .
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9