Velopex Intra-X - Velopex Processor Cleaning

Velopex Processor Cleaning
VELOPEX INTRA-X 15
User Guide
MAINTENANCE
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
1.
Remove old film wrappers from
daylight loader. Wipe clean the
interior of loader.
TIP: The interior of the daylight loader
should be cleaned with cold sterilising
solution. Wipe dry after appropriate
period.
WARNING: Wear gloves -
contamination Biohazard.
Dryer Module Cleaning - Place
Module in container or sink filled
with fresh cold water. Add one
Velopex Cleaning Tablet and
soak for at least 10 minutes. Rinse
thoroughly with water to remove
all cleaning solution.
TIP: Add a little domestic fabric
softener to the washing water
to avoid ‘static’. DO NOT USE
FABRIC SOFTENER ON THE OTHER
MODULES!
WARNING: Make sure you drip-dry
the module before replacing in the
dryer compartment.
2.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
6%,/0%8).42!8
5SER'UIDE
-!).4%.!.#%

6ELOPEX0ROCESSOR#LEANINGCONT
$RYER-ODULE#LEANING0LACE
-ODULEINCONTAINERORSINK
lLLEDWITHFRESHCOLDWATER!DD
ONE6ELOPEX#LEANING4ABLET
ANDSOAKFORATLEASTMINUTES
2INSETHOROUGHLYWITHWATERTO
REMOVEALLCLEANINGSOLUTION
7!2.).' -AKESUREYOU
DRIPDRYTHEMODULEBEFOREREPLACING
INTHEDRYERCOMPARTMENT
2EPLACE-ODULESANDRUN
FOR47/CYCLESATOPERATING
TEMPERATURE


!DD6ELOPEX#LEANING4ABLETS
ONEPERTANK

4)0 !DDALITTLEDOMESTICFABRIC
SOFTENERTOTHEWASHINGWATERTOAVOID
@STATIC$/./453%&!"2)#3/&4%.%2
/.4(%/4(%2-/$5,%3