Velopex Intra-X - Filling with Chemicals

Filling with Chemicals (Cont.)
INSTALLATION
8 VELOPEX INTRA-X
User Guide
14.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
To avoid spillage, carefully return
tanks to the machine. Start with
the Developer tank followed by
the Fixer, Water and finally the
Dryer tanks. Engage the module
drive pins into the drive dogs,
working from right to left.
TIP: Slide the developer and fixer
tanks sideways onto the immersion
heaters till backed up fully against
the machine internal wall.
Return side panel and lid.
WARNING: Wipe dry any spilled
solution.
The machine may now be
switched on.
TIP: Check that all modules are
engaged and running smoothly by
passing a ‘clean-up film’ through the
machine. If it fails to exit the machine,
check engagement of modules.
WARNING: The machine will not
operate with the lid open.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
15 a .
15 b .
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9