Velopex Intra-X - Page 18

Operating the Processor (Cont.)
10 VELOPEX INTRA-X
User Guide
OPERATION
(Images for instruction ONLY)
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
4.
5.
6.
Put hands through loading ports
and place film inside Daylight
Loader.
WARNING: Always remove old film
wrappers from the loader.
Put hands through Loading Gloves
and strip wrapping from film, insert
film into Entry Slot. Touch the Film
Entry Slot to initiate processing. A
bleep will indicate film detected.
When liquid levels are below the
sight glass, top up Chemicals and/
or water (See Installation Sections
10, 11 and 12)
TIP: Before processing, run through
“clean-up film” or any spare strip of
extra oral film. This helps to clean the
transport system.
WARNING: The same film may be used
for this purpose for one week, after
which discard the old film and use a
fresh one.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9