Velopex Intra-X - Processor Maintenance Procedures; Changing Processor Chemistry

Operating the Processor (cont.)
Velopex Processor Changing Chemistry
VELOPEX INTRA-X 13
User Guide
MAINTENANCE
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
1.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
It is suggested that the VISCHECK
Quality Manager be used to
ensure consistent quality X-Rays.
TIP: Regular use of this product
will ensure that the quality of the
film processing is maintained and
reduce the risk of retakes. Vischeck
will also tell you when to change the
chemicals. VISCHECK is available
from your Velopex stockist.
Open Lid, remove side cover,
tanks & modules (see Installation
sections 1-3b & 8-9).
WARNING: Carry out the cleaning
routine at each chemical change,
approx. once every three to four
weeks, according to use.
Empty tanks and dispose of
chemistry.
TIP: Drain modules over the tanks
before removing them.
WARNING: Use gloves and handle
with care. Be aware that chemicals
can cause staining or corrosion of
surfaces and may cause skin and eye
irritation. Wipe away any spillage
immediately and flush with copious
amounts of water.
2.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9
3.
6%,/0%8).42!8
5SER'UIDE
/0%2!4)/.

/PERATINGTHE0ROCESSOR
4HE6ELOPEXISEQUIPPEDWITH
AUTOMATICSTANDBYMODE4O
INITIATEPROCESSINGFEEDlLM
THROUGH%NTRY3LOT)FTHATFAILS
TOWORKSLIDElNGEROVER@25.
3ENSOR
4)0 4HETIMETAKENTOACHIEVETHE
CORRECTTEMPERATUREDEPENDSONTHE
ROOMTEMPERATUREUSUALLYMIN
7!2.).' "EFOREPLACINGIN
THEMACHINEINTRAORALlLMPACKETS
SHOULDBEWIPEDCLEANOFALLMOUTH
CONTAMINANTS

0LUGINELECTRICCORDANDSWITCH
ON4HEMACHINEWILLTHENRUN
THROUGHAHIGHSPEEDSTARTUP
CYCLEOFMINUTES
4)0 !FTERAPPROXTENMINUTESTHE
PROCESSORWILLGOINTO@STANDBYMODE
BYWHICHTIMETHECHEMICALSWILLHAVE
REACHEDTHEIRCORRECTTEMPERATURE
7!2.).' !LWAYSTURN
MAINSELECTRICITYSWITCHOFFATNIGHT
)NCORRECTTEMPERATUREISINDICATED
WHENTHEMESSAGEONTHE,%$
DISPLAYREADShT,Ov2EADYTOUSE
ISINDICATEDBYTHREEHORIZONTAL
CENTRALLINESANDCOOLINGDOWNIS
INDICATEDINTHELINESDESCENDING
FROMLEFTTORIGHT


)MAGEFORINSTRUCTION/.,9
6IEWING7INDOWISCLOSEDWHEN
OPERATINGMACHINE
)MAGESFORINSTRUCTION/.,9