Velopex Intra-X - Page 28

Troubleshooting (Cont.)
20 VELOPEX INTRA-X
User Guide
TROUBLE SHOOTING
6%,/0%8).42!8
5SER'UIDE
42/5",%3(//4).'

.O 39-04/- 0/33)",%#!53% !#4)/.3
 &ILMSTOO,IGHT
#HEMICALS%XHAUSTED
2EPLACEWITHFRESHTHISWILLDEPENDONVOLUMEOFlLMBEINGPROCESSEDANDLENGTHOFTIME SINCELASTCHEMICALCHANGE
#HEMICALS #ONTAMINATED
#LEANMACHINEREPLACECHEMICALSWITHFRESHSOLUTIONS
$EVELOPER)NCORRECTLY -IXED
2EPLACEWITHFRESHIFRELEVANT
#HEMICAL,EVELTOO,OW4OPUP 4EMPERATURETOO,OW 8%EXCLUDED
)FDISPLAYMESSAGEDOESNOTGOOUTCHECKWITHATHERMOMETERGENERALLYSETAT$EVELOPER& #&IXER&#IFSIGNIlCANTLYBELOWTHESETEMPERATURESCALLFORSERVICE
&ILM%XPOSURE #HECKlLMSHAVEBEENEXPOSEDCORRECTLY
 &ILMS$IRTYOR-ARKED
7ATER4ANK$IRTY
#LEANMODULETHOROUGHLYANDCHANGEWATERDAILYINSUFlCIENTCLEANINGCANLEADTOABUILDUP OFALGAE
4RANSPORT-ODULES $IRTY
#HECKTRANSPORTMODULESAREBEINGCLEANEDCORRECTLYSEECLEANINGINSTRUCTIONSABOVE
#HEMICAL,EVELTOO,OW4OPUP 7RONG0OSITIONINGOF -ODULES
)FFOUNDINWRONGORDERCONTAMINATIONWILLHAVEOCCURRED4HOROUGHLYCLEANMODULESAND TANKSRElLLWITHFRESHCHEMICALS
,IGHT,EAKS #HECKFORSTRAYLIGHTENTERINGMACHINEPROCEEDASFORFOGGINGSEESYMPTOM

3UDDEN#HANGEIN )MAGE$ENSITY
7RONG3OLUTIONS -AKESURESOLUTIONSAREINCORRECTTANKS $EVELOPER #ONTAMINATION
2EPLACE$EVELOPERIFCONTAMINATEDWITH&IXER
4EMPERATURE #HECK$EVELOPERTEMPERATURE 8RAY5NIT #HECK8RAYUNIT