Viking Range 30” W - User Manual

INSTALLATION
INSTRUCTIONS
DUAL FUEL RANGES
VIKING RANGE CORPORATION
111 Front Street
Greenwood, Mississippi 38930 USA
(662) 455-1200
IMPORTANT - PLEASE READ AND FOLLOW
•Before beginning, please read these instructions completely and carefully.
•Do not remove permanently affixed labels, warnings, or plates from the product. This may void the warranty.
•Please observe all local and national codes and ordinances.
•Please ensure that this product is properly grounded.
•The installer should leave these instructions with the consumer who should retain for local inspector’s use and for future
reference.
Installation must conform with local codes or in the absence of codes, the National Fuel Gas Code ANSI Z223.1-latest
edition. IN CANADA: Installation must be in accordance with the current CAN/CGA B149.1 & 2 Gas Installation codes
and/or local codes. Electrical installation must be in accordance with the current CSA C22.1 Canadian Electrical Codes
Part 1 and/or local codes.
In Massachusetts: All gas products must be installed by a “Massachusetts” licensed plumber or gasfitter. A “T” type
handle manual valve must be installed in the gas supply line to the appliance.
1. Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
2. WHAT TO DO IF YOU SMELL GAS:
•Do not try to light any appliance.
•Do not touch any electrical switch; do not use any
phone in your building.
•Immediately call your gas supplier from a neighbor’s
phone.
•Follow the gas supplier’s instructions.
•If you cannot reach your gas supplier, call the fire
department.
3. Installation and service must be performed by a
qualified installer, service agency, or the gas supplier.
WARNING
If not installed, operated and maintained in
accordance with the manufacturer’s instructions, this
product could expose you to substances in fuel or
from fuel combustion which can cause death or
serious illness and which are known to cause
cancer, birth defects, or other reproductive harm.
WARNING: IF THE INFORMATION IN
THIS MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION MAY
RESULT CAUSING PROPERTY DAMAGE,
PERSONAL INJURY, OR DEATH.
For example, benzene is a chemical which is
part of the gas supplied to the cooking
product. It is consumed in the flame during
combustion. However exposure to a small
amount of benzene is possible if a gas leak
occurs. Formaldehyde and soot are by-
products of incomplete combustion. Properly
adjusted burners with a bluish rather than
yellow flame will minimize incomplete
combustion.
WARNING!
•This range can tip.
•Injury to persons could result.
•Install anti-tip device packed with range.
•See Installation Instructions
WARNING
Frame grounded to neutral of appliance through a link. If local codes do not permit grounding through the neutral, the
3-conductor cord or cable assembly must be replaced by a 4-conductor cord or cable assembly. See manufacturer’s
instructions.

Summary

Key Safety Warnings and Precautions

General Safety Warnings

Key safety warnings regarding fire, explosion, and exposure to chemicals.

General Installation and Safety Guidelines

Electrical Grounding Instructions

Mandatory instructions for proper electrical grounding of the appliance.

Range Leveling and Stability Device Installation

Leveling and Alignment Procedures

Steps for ensuring the range is level and properly aligned for optimal performance.

Anti-Tip Device Installation

Instructions for installing the anti-tip device to prevent range tipping.

Gas Connection Procedures and Requirements

Gas Shut-off Valve and Regulator

Procedures for installing the manual shut-off valve and pressure regulator.

Power Cord Electrical Connections

3-Wire Power Supply Cord Installation

Step-by-step guide for connecting a 3-wire power supply cord.

4-Wire Power Supply Cord Installation

Conduit Electrical Connections

3-Wire Conduit Connection

4-Wire Conduit Connection

Gas Conversion and Burner Adjustment Procedures

LP;Propane Conversion (Open Top)

Procedure for converting open top burners from natural gas to LP/Propane.

Surface Burner Adjustments

Sealed Burner Gas Conversion and Adjustment

LP;Propane Conversion (Sealed Top)

Procedure for converting sealed top burners to LP/Propane gas.

Sealed Top Burner Adjustment

Final Checks, Cleaning, and Parts

Initial Ignition and Performance Checks

Verifying burner ignition and overall appliance performance after installation.

Dual Fuel Range Wiring Diagrams

30 & 36 Dual Fuel Wiring Diagram

Dual Fuel Range Wiring Diagram Details

30 & 36 Dual Fuel Wiring Details

485 Model Dual Fuel Wiring Diagram

485 Dual Fuel Wiring Diagram

Canadian 485 Dual Fuel Wiring Diagram

Canadian 485 Dual Fuel Wiring Diagram

487 Model Dual Fuel Wiring Diagram

487 Dual Fuel Wiring Diagram

Canadian 487 Dual Fuel Wiring Diagram

Canadian 487 Dual Fuel Wiring Diagram

Viking Range 30” W Specifications

General

Brand	Viking Range
Model	30” W
Category	Ranges
Language	English