Vmac VR70 - Page 3






ServiceTips


• Neverrunthecompressor,drivethevehicleorevenallowthevehicletositparkedwithoutthe
recommendedairfilterandfiltercoverinstalled.

• AlwaysuseaVMACoilfilterwhichisdesignedtowithstandthehighpressures,notan
automotivefilter.

• Operatethesystemat
leastevery30daysfor15minutesatnoloadtoensurebearing
lubricationandrotation.Impactdamageandprematurebearingfailuremayoccurinthe
compressorbearingsifthesystemisnotoperatedonaregularbasisduetovibra tioncausedby
truckoperation.

• Neverattempttoclean
thefilterelementwithcompressedair.Replacethefilterelement.

• Donotattempttochangetheoilfilteruntiltheoilhascooled.Hotoilcancausesevereburns.

• Neverover‐tightenthefilter,asthismaydamagethesealorthefilter.

• Useonlythe
suppliedcompressoroilinthissystem.Failuretousethisspecialoilwillresultin
damagetothecompressorandwillvoidyourwarranty.

• Donotoverfillthesystem.Overfillingthesystemwithoilcanfloodthesightglasswindowand
makethesystemappearempty.

• If
youusesolventsforcleaning,thoroughlyrinsethepartswithhotwatertoremoveallsolvent
residues.

• Checktheinsideofthetankforanyevidenceofmetalfilingsorcontamination;iffound,flush
thetank,hosesandcooler.Metalfilingswilldamagethecompress or.
