Volare Marcopolo - Page 28

28
PREVENTIVE MAINTENANCE CHART - Volare W8 and W9
DESCRIPTION
VOLUME
LUBRICATION
5.000 Km
10.000 Km 15.000 Km 20.000 Km 25.000 Km 30.000 Km 35.000 Km 40.000 Km 45.000 Km 50.000 Km 55.000 Km 60.000 Km 65.000 Km 90.000 Km 95.000 Km
100.000 Km 105.000 Km 110.000 Km 115.000 Km 120.000 Km
70.000 Km 75.000 Km 80.000 Km 85.000 Km
WEEKLY
DAILY
ENGINE
Check / Inspect
Antifreezer Note 4
Compressed-air Pump Note 4
Ventilator Funnel Note 4
Vibration Supressor Note 4
Belt Tightener Bearing Note 4
Turbo-compressor Check gap of the rotor axle and frame state
Ventilator Check its state, switched-on/off temperature Note 4
Adjust gap of the valves (only in engines with mechanical adjustment) Note 4
High-pressure Pump
Maintenance is not performed Note 9 Every time when a fault or a problem occurs, check at a BOSCH service station
Cones (electro-injectors)
Lubricating Oil Filter
Fill 1,2 litres
Chart 1
Change and fill
Crankcase
Check level and fill up 8 litres
Chart 1
Change oil Note 4 e 5
Check engine electic connections
Re-tighten parts and external fixing screws
Check torques of the pads, re-tighten if necessary
Belts
Check tention state
Replace
The points mentioned in the chart are described on page 27.
COOLING SYSTEM
Compensating reservoir
(complete system)
Check level and fill up Note 3 Fill up daily, if necessary, with clean water and additive agent in the indicated proportion
Drain and re-fill with water and additive agent Note 3 Change every 350 000 km or 3 years (depending on what occurs first)
Water-Level Sensor Remove and clean
Check for leakage and re-tighten joints