Weber Rescue Systems SPS 270 E-FORCE 2 - Pulling (Spreaders, Combi Devices)

 

5.5Pulling(spreaders,Combidevices)
Aerthechainset(asexplainedinchapter4.7)hasbeenmountedonthespreaderps,the
combidevicecanalsobeusedforpulling.
Forthis,thechainsmustbeghtlytensionedandmustbetensedonlyinthepullingdirecon.
Totensionthechain,onlyonelockcanbepressedin,sothatthechaincanbepulledthrough
the holder.
Iftherangeofmovementisnotsucient,tensionchainsorothermeansmustbeusedsothat
the spreader can be reopened and the chain retensioned.

Storethepullingchainswithlocksmountedabout10–20cmfromtheend.
Checkthechainspriortoeveryuse.Checkthattheweightdoesnotstress
thepofthehook,butliesinthemiddleofthehookinstead.
» Donotmakeanyrepairsonyourown.
» Donotstressthechainsbeyondthepermiedloadcarrying
capacity.
» Donotloadwithajerkingmovement.
» Donotgalvanizeorpaintthechains.
» Donotshortenthechainbyknongit.
» Donotsubjectthechainstoheatstress.
» Usethechainsandaccessoriesonlybetween–40°Cand+200°C.
» Duringallmaintenancework,observetheapplicableGerman
 accidentprevenonregulaons(UVV)aswellasthespecicaons
 ofDINEN818-7andDIN685-5.
» Chainsmustonlybeusedforlashing.Liingloadsisnot
 permied.
