Willys MB - CHAPTER 1 INTRODUCTION; SCOPE.

WILLYS MODEL "MB" %-TON 4 x 4 GOVERNMENT TRUCK
3.
GENERAL DATA
ENGINE
Type..
.................................................... .Gasoline
Number of Cylinden.. ...................................... .4
Bore.. ....................................................
.3 x::
Stroke. ................................................... ,434
Piston Displacement ........................................ ,134.2 cu. in.
Compression Ratio. ......................................... .6.48-1
Horsepower-S.A.E.. ................. : ...................... .15.6
Actual.. ...................................... .G0
Revolutions per minute.. ....................... .4000
Horsepower { .
Torqiie Maximum Lbs.-Ft .................................. .l05
I Revolutions oer Minute. ........................... .Z000
Wheelbase ....................................
Tread. ............................ .48%"-with
Overall Widtli .................................
Overall Lengtli.. ..............................
Overall Height-Normal Load
To top of cowl.
.......................
To top of steering wheel.. ..............
Topup ...............................
Weight-Maxinium Pay Load.. .................
............... Maxiiniiin Trailed Load.
Shipping (Less water, fuel aiid cliains). ..
Koad
Gross ................................
.............. 80"
I combat wlieels 49"
.............. C2"
............. .132%"
............. .40"
............. .5 1 X!'
.............. 69W
.............. 800 Ibs.
............. ,1000 Ibs.
............. ,2125 Ibs.
............. ,2315 Ibs.
............. .3125 Ibs.
CAPACITIES
U.S. Imperial Metrlc
Fuel Tank (Cals.). .................................
.l5 12% 56.78 liters
Eiigine Crankcase-Refill (Qts.). ...................... .4 3%
3.78 "
Cooling Systerii (Qts.). ..............................
l1 I 10.41 "
Traiismission (Pts.) ................................ .2 l
.95 "
Transfer Case (Pts.). ...............................
.9 2% 1.42 "
Front Axle Oifferential (Pts.). ....................... .Z% 2 1.18 "
liear Axle Difícrential (I'ts.). ........................
.3% 2 1.18 "
Oil Bath Air Cleaner (Pts.). ..........................
l >.i 1 .71 "
Brake Systeni Rrake Fluid (Pts.). .....................
. X .3li "
See 1.librication Chart, Page 12
1,AMP BU1,BS Mazdri
Head Lamp (Sealed Beam type). ............................. .Z400
Upper Beam.. ..................................... .45 Watts
Lower
Ream.. ..................................... .4,5 Watts
Blackout Lamp Bulb (1).
.................................... .3 Cp. SC G3
Left Tail Lamp Rulb (1). ................................. .-l-3 Cp. DC 1154
Left Tail Lamp Rulb (1). .................................... .3 Cp. SC 63
Right Tail Lamp Bulbs (2). .................................. .3 Cp. SC (i:<
Instrument Lamp Bulb (2). ................................ .1.5 Cp. SC 51
Fuse
(Thermal Type)-On Light Switch-30 Amperes
Chassis Serial Kumber locoted on inside of frame at
Ieft Iroiit end.
Engine Numl~cr lucated on right side of cylinrlcr block
iron1 upper corner.