EasyManua.ls Logo

Yard-Man 247.27432 - User Manual

Yard-Man 247.27432
40 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
OPERATOR’S MANUAL
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
MTD PRODUCTS INC. P.O. BOX 368022 CLEVELAND, OHIO 44136-9722
PRINTED IN U.S.A. FORM NO. 770-10236
Warning:
This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-
covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting
applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.
In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized
service dealer or contact the service department, P.O. Box 368022 Cleveland, Ohio 44136-9722.
(1/99)
AutoDrive
™
Lawn Tractor
Models 247.274020
(13AX604G402)
247.274320
(13AU604H402)

Table of Contents

Questions and Answers

  • B
    Brandon HicksJul 30, 2025
    Why Yard-Man 247.27432 Lawn Mower engine cranks but won't start?
    • I
      icurryJul 30, 2025
      If your Yard-Man Lawn Mower's engine cranks but doesn't start, several factors could be at play. Ensure the throttle or choke is in the correct starting position as detailed in the operation section of the manual. Check if the gasoline tank is empty and fill it if needed. A plugged fuel line or in-line fuel filter could also be the culprit; remove and clean the fuel line, and replace the fuel filter if necessary. Verify the spark plug lead is connected. If there's no spark, use a spark tester to check for spark and have the engine’s magneto serviced by an authorized engine dealer if needed. Also, refer to the engine manual to check the air cleaner.
  • J
    John HughesAug 11, 2025
    What to do if Yard-Man 247.27432 Lawn Mower won’t discharge grass or leaves uncut strips?
    • C
      christopherhendersonAug 11, 2025
      If your Yard-Man Lawn Mower isn't discharging grass properly or leaves uncut strips, several factors could be the cause. Ensure the engine speed is set to full throttle. Adjust the speed selection to a lower ground speed. Check the cutting height and raise the deck if it's set too low. Additionally, if you're experiencing uncut strips, the blades may be dull, so sharpen or replace them.
  • M
    michael80Aug 17, 2025
    Why Yard-Man 247.27432 engine smokes?
    • C
      cvaughanAug 17, 2025
      If your Yard-Man Lawn Mower engine is smoking, it could be due to a few reasons. First, check the engine oil level, as the engine oil may have been overfilled. Another potential cause is the engine losing crankcase vacuum, which could be due to a dipstick that is not seated or broken; replace the defective part. The engine breather may also be defective and need replacement.
  • M
    Michael Chang DVMAug 23, 2025
    How to stop excessive vibration in Yard-Man Lawn Mower?
    • N
      nlambAug 25, 2025
      If your Yard-Man Lawn Mower is experiencing excessive vibration, stop the engine immediately. Inspect all pulleys, blade adapters, keys, and bolts for tightness and any spindle damage. Tighten or replace any loose or damaged parts. Always replace a damaged blade, using only original equipment blades.
  • P
    Patrick LeeNov 4, 2025
    How to fix Yard-Man Lawn Mower when engine will not crank?
    • E
      Emily PhillipsNov 4, 2025
      If your Yard-Man Lawn Mower engine won't crank, it could be due to several reasons. First, make sure the safety switch button is fully depressed by the actuator. Check the battery installation, ensuring the negative terminal (marked with “NEG”, “N” or “-”) is connected to the black ground wire and the positive terminal (marked with “POS”, “P” or “+”) is connected to the thick red wire going to the solenoid. A dead or weak battery could also be the problem; charge it with a 12-volt automotive-type battery charger at six amps for one hour or until fully charged. Check for a blown fuse and replace it with an automotive type fuse of the proper amperage, referring to the operator’s manual for fuse location. Also, examine the fuse holder for loose connections and replace it if necessary. Look fo...

Summary

Finding Your Model Number

Calling Customer Support

Important Safe Operation Practices

Slope Operation

Guidance for operating the tractor safely on slopes to prevent tip-overs and loss of control.

Children

Safety precautions to prevent accidents involving children near the operating tractor.

Service

Guidelines for safe handling of fuel, fluids, and proper disposal of waste materials.

Attachments & Accessories

Tractor Set-Up

Attaching the Battery Cables

Connect positive and negative battery terminals correctly to ensure proper function.

Gas and Oil Fill-Up

Service the engine with gasoline and oil as instructed. Check oil level before operating.

Installing the Mulch Kit

Instructions for installing the mulch kit on 42-inch and 46-inch decks.

Controls

Ignition Switch

Controls for starting the engine and operating headlights.

Throttle Control Lever

Lever to control engine speed and potentially choke function.

Choke Control

Activates choke plate for easier engine starting.

Indicator Monitor; Hour Meter

Displays battery, oil lights, and tracks tractor operating hours.

Key Controls

Key Controls

Covers Lift Lever, Electric PTO, AutoDrive Pedal, Brake Pedal, Parking Brake Button, and Shift Lever functions.

Operation

Cruise Control Button

Engages cruise control for maintaining a set forward speed.

Seat Adjustment Lever

Allows forward or backward adjustment of the operator's seat.

Cup Holder

Convenient location for drinks.

Safety Interlock Switches

System to protect the operator by preventing starting or operation under unsafe conditions.

Engine Operations

Engine Operations

Covers setting cutting height, starting, stopping the engine, and driving the tractor.

Cruise Control Operation

How to engage and disengage the cruise control feature.

Driving on Slopes

Driving on Slopes

Safety guidelines and techniques for operating on inclines.

Operating the Headlights

Instructions for turning the tractor's headlights on and off.

Using the Lift Lever

How to raise or lower the cutting deck.

Engaging the Electric PTO (Power Take-Off) Knob

Procedure for engaging power to attachments like the cutting deck.

Adjustments

Leveling the Deck

Adjusting the cutting deck for proper front-to-rear and side-to-side balance for an even cut.

Seat Adjustment

Adjusting the seat position forward or backward for operator comfort.

Steering Adjustment

Adjusting drag links for proper steering alignment and toe-in.

Carburetor Adjustment

Guidelines for adjusting the engine's carburetor.

Brake Adjustment

Procedure for adjusting the tractor's brake system for proper stopping.

Maintenance

Engine Maintenance

Instructions for checking oil levels and changing engine oil.

Cleaning the Engine and Deck

Procedures for cleaning the tractor's engine and cutting deck.

Cutting Deck Removal

Steps to safely remove the cutting deck from the tractor.

Changing the Deck Belt(s)

Instructions for replacing the drive belts on the cutting deck.

Changing the Transmission Drive Belt(s)

Procedure for replacing the transmission drive belts.

Drive Belts

Instructions for replacing upper and lower drive belts on the tractor.

AutoDrive Pedal Adjustment

Adjusting the AutoDrive™ pedal for proper travel and function.

Cutting Blades & Battery

Instructions for sharpening/replacing blades and battery maintenance.

Lubrication

Engine Lubrication

Lubricating the engine with motor oil as per the engine manual.

Pivot Points & Linkage

Lubricating pivot points and linkage with oil or grease.

Steering Gear & Wheels

Lubricating steering gear and wheel axles for smooth operation.

Front Axles

Lubricating front axles with a grease gun, often via zerk fittings.

Troubleshooting Guide

Engine Starting Issues

Diagnosing and correcting problems when the engine won't crank or start.

Engine Performance Issues

Troubleshooting smoking, vibration, and poor discharge.

Electrical System; Tractor Body

Tractor Body Parts Diagram

Exploded view of tractor body components and electrical system parts.

Lift Assembly

Lift Components

Details on lift shaft, lever, and seat adjustment components.

Steering Assembly

Frame and Steering Components

Parts related to the lower frame, steering gear, and steering mechanism.

Wheel Assemblies

Details on the tractor's wheel assemblies and related parts.

Drive System

Drive System Components

Details on pulleys, belts, brake control, and AutoDrive pedal assemblies.

Power Take-off System

PTO System Components

Details on electric PTO clutch, idler brackets, and battery tray.

Cutting Decks

Deck Components

Details on spindle assembly, chute, deck wheels, and blades.

Engine Accessories

Engine Exhaust and Control Components

Details on muffler deflector, exhaust pipes, and throttle cables.

Manufacturers Limited Warranty

Warranty Service and Other Warranties

Procedures for obtaining service and details on other product warranties.

Yard-Man 247.27432 Specifications

General IconGeneral
BrandYard-Man
Model247.27432
CategoryLawn Mower
LanguageEnglish

Related product manuals